TROUBLESHOOTING
PROBLEM | _ | CAUSE / REMEDY (SEE INDEX) |
Fil! Tank with Gasoline, Check Fuel Line and Carburetor
(clean if necessary). Replace Fuel Filter Use Fresh Fuel
WILL NOT STARTRecharge or replace Battery Check' Wiring
Replace Spark Plug(s) and adjust gap
Drain and replace oit for proper temperature
| Push | Clutch/Brake |
| Pedal | into brake | position |
| ||
| Charge | or replace | Battery |
|
|
|
| ||
| Move | Attachment |
| ClutchSwitch | to | "'D ISENGA G ED '" position | |||
WILL NOT TURN OVER | Replace | Ignition |
| Switch |
|
|
|
| |
Replace | Interlock |
| Switch | (es) |
|
|
| ||
| Replace | Solenoid | or Starter |
|
|
| |||
| Replace | Fuse |
|
|
|
|
|
| |
| Check |
| all Wire | Connections | and | "Ground" | Points | ||
| Reattach | Tiller | Attachment | Wire | Loop |
| |||
ENGINE CLICKS BUT WON'T START
HARD TO START
ENGINE MISSES OR LACKS POWER
ENGINE OVERHEATS
Clean Battery TerminaLs Replace Starter or Solenoid
Charge or Replace Battery
Check Wire Connections and "Ground" Points
Place Throttle Control in
Remove Air Filter and clean
Replace Spark' Plug(sf and adjust gap Recharge or replace Battery
Check the Wiring
Drain Fuel Tank and Carburetor Use Fresh Fuel Replace Fuel Filter
Make necessary adjustments to Carburetor Major Engine Overhaul
Shift to a lower gear or reduce toad
Drain Gas Tank and Carburetor Use Fresh Fuel Remove and clean Air Cleaner
Make necessary carburetor adtustments Clean Air Screen
Add or change oil
Replace Spark Plug(s) and adjust gap
Replace Fuel Filter
Major Engine Overhaul
Shift to lower gear or reduce load
Clean Air Screen
Add or change od
Clean Engine Cooling Fins
Remove and clean Muffler or replace
Remove and clean Air Filter
Use fresh fuet and adjust Carburetor
NO LIGHTS
WON'T CHARGE
Check Fuse, Switch and Wire Connections Replace
Headlight Bulbs
Replace Switch
Check Fuse for fault and replace
Replace Battery
Replace Diode Assembly
Replace Alternator
OPERATOR PRESENCE SYSTENI WILL NOT SHUT
Check all Wire Connections
DOWN ENGINE WHEN OPERATOR LEAVES SEAT Check Seat Switch
NOTE: This tractor' is equipped with an operator presence sensing system, Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut down the engine.
26
