Manuals / Snapper / Lawn and Garden / Lawn Mower

Snapper LT160H42FBV2, LT180H48FBV2 important safety instructions Primary Maintenance

Models: LT160H42FBV LT180H48FBV2 LT160H42FBV2

1 44

Download 44 pages 46.28 Kb

Page 39

Image 39

PRIMARY MAINTENANCE

Page 39

Image 39

Snapper LT160H42FBV2, LT180H48FBV2 important safety instructions Primary Maintenance

Contents

LT160H42FBV LT160H42FBV2 LT180H48FBV2 Safety Instructions & Operator’s Manual forLAWN TRACTOR HYDROSTATIC DRIVE ELECTRIC CLUTCH SERIES F MODELSPREPARATION IMPORTANT SAFETY INSTRUCTIONSPROTECTION FOR CHILDREN PROTECTION AGAINST TIPOVERSPREPARATION MAINTENANCEOPERATION IMPORTANT SAFETY INSTRUCTIONSTABLE OF CONTENTS IMPORTANT SAFETY INSTRUCTIONSTROUBLESHOOTING GUIDE Section 1 - FAMILIARIZATION COMPONENTSCONTROLS Section 2 - OPERATING INSTRUCTIONS 2.1 PRE-START CHECKLIST2.2 OPERATOR’S SEAT ADJUSTMENT 2.2.1. FRONT TO REAR ADJUSTMENT 2.3 STARTING & OPERATION 2.3.1. STARTING ENGINE Section 2 - OPERATING INSTRUCTIONS2.4 STOPPING ENGINE, BLADE, WHEEL DRIVE 2.4.1 STOPPING ENGINE Section 2 - OPERATING INSTRUCTIONS2.3 STARTING & OPERATION Continued 2.3.2. STARTING WHEEL DRIVE 2.3.3 STARTING MOWER BLADE2.4 STOPPING 2.4.3. STOPPING MOWER BLADES Section 2 - OPERATING INSTRUCTIONS2.6. ROLLING TRACTOR WITH ENGINE OFF Rolling Hydro Models Section 2 - OPERATING INSTRUCTIONS3.2.1. CHANGE ENGINE OIL Section 3 - MAINTENANCE3.2 SERVICE - AFTER FIRST 5 HOURS 3.1 INTRODUCTION3.2.4. CHECK DECK DRIVE BELT Section 3 - MAINTENANCE4. Steering Sector Gear Section 3 - MAINTENANCE3.3.4. TRACTOR LUBRICATION Continued From Previous Page 3. Clutch/Brake Pivot3.4.2. FUEL FILTER Section 3 - MAINTENANCE3.4 ANNUALLY END OF EACH SEASON 3.4.1. ENGINESection 4 - ADJUSTMENT & REPAIR 2. Move sector plate as required to raise or lower the rear of deck Section 4 - ADJUSTMENT & REPAIRFRONT LIFT ARM Section 4 - ADJUSTMENT & REPAIRPLACE THREE 2 X 4 UNDER FRONT AND REAR OF DECK FRONT LIFTRODDECK BRACKETSWIVEL Section 4 - ADJUSTMENT & REPAIRREAR LIFT ROD REMOVE WASHER & HAIR PIN ROTATE SWIVEL UP OR DOWN REMOVE WASHER & HAIR PIN ROTATE SWIVEL UP OR DOWN SWIVEL FRONT LIFTTo be properly adjusted, the brake should stop Section 4 - ADJUSTMENT & REPAIR4.3.3. SHIFTER ADJUSTMENT Continued from page Section 4 - ADJUSTMENT & REPAIR22º TO 28º STANDARD BLADE Section 4 - ADJUSTMENT & REPAIRNEW BLADE WEAR LIMIT. CRACKS OR NOTCHES BEGIN TO APPEAR DANGEROUS CONDITION DO NOT USE ON MOWERDECK/DRIVE Section 4 - ADJUSTMENT & REPAIR2. Turn engine “OFF”. Remove key 3. Lower the deck to lowest setting Section 4 - ADJUSTMENT & REPAIR10. Make note of hole used in sector plates Section 4 - ADJUSTMENT & REPAIRSection 4 - ADJUSTMENT & REPAIR 42” DECK SHOWN Section 4 - ADJUSTMENT & REPAIRTraction drive belt replacement VIEW FROM UNDERNEATH TRACTOR1. Place tractor on a firm level surface Section 4 - ADJUSTMENT & REPAIRSection 4 - ADJUSTMENT & REPAIR Section 4 - ADJUSTMENT & REPAIR REMOVE ADJUSTING KNOBS AND MOVE SEAT FORWARDREMOVE POSITIVE + CABLE LAST REMOVE NEGATIVE CABLE FIRST 4.5.5. BATTERY TESTING Section 4 - ADJUSTMENT & REPAIR2. Remove spindle pulley from spindle shaft Section 4 - ADJUSTMENT & REPAIRAVAILABLE Section 4 - ADJUSTMENT & REPAIRAVAILABLE ACCESSORIES ACCESSORIESMODEL - LT160H42FBV SECTION 5 - ELECTRICAL SYSTEMSECTION 5 - ELECTRICAL SYSTEM MODELS - LT160H42FBV2 & LT180H48FBV2CORRECTIVE ACTION TROUBLESHOOTING GUIDEPROBLEM PROBABLE CAUSETROUBLESHOOTING GUIDE DRIVE BELTS MAINTENANCE SCHEDULEMAINTENANCE PARTS TRACTOR3 YEAR LIMITED WARRANTY PRIMARY MAINTENANCE PRIMARY MAINTENANCE PRIMARY MAINTENANCE PRIMARY MAINTENANCE SERVICE NOTES Safety Instructions & Operator’s Manual for Snapper products are built using engines that meet or exceed all applicable emissions requirements on the date manufactured. The labels on those engines contain very important emissions information and critical safety warnings. Read, Understand, and Follow all warnings and instructions in this manual, the engine manual, and on the machine, engine and attachments. If you have any questions about your Snapper product, contact your local authorized Snapper dealer or contact Snapper Customer Service at Snapper, McDonough, GA. 30253. PhoneLAWN TRACTOR HYDROSTATIC DRIVE ELECTRIC CLUTCH SERIES F