Manuals / Snapper / Lawn and Garden / Lawn Mower

Snapper LT160H42FBV2, LT180H48FBV2 important safety instructions Primary Maintenance

Models: LT160H42FBV LT180H48FBV2 LT160H42FBV2

1 44

Download 44 pages 46.28 Kb

Page 42

Image 42

PRIMARY MAINTENANCE

Page 42

Image 42

Snapper LT160H42FBV2, LT180H48FBV2 important safety instructions Primary Maintenance

Contents

MODELS Safety Instructions & Operator’s Manual forLAWN TRACTOR HYDROSTATIC DRIVE ELECTRIC CLUTCH SERIES F LT160H42FBV LT160H42FBV2 LT180H48FBV2PROTECTION AGAINST TIPOVERS IMPORTANT SAFETY INSTRUCTIONSPROTECTION FOR CHILDREN PREPARATIONIMPORTANT SAFETY INSTRUCTIONS MAINTENANCEOPERATION PREPARATIONTABLE OF CONTENTS IMPORTANT SAFETY INSTRUCTIONSTROUBLESHOOTING GUIDE Section 1 - FAMILIARIZATION COMPONENTSCONTROLS Section 2 - OPERATING INSTRUCTIONS 2.1 PRE-START CHECKLIST2.2 OPERATOR’S SEAT ADJUSTMENT 2.2.1. FRONT TO REAR ADJUSTMENT Section 2 - OPERATING INSTRUCTIONS 2.3 STARTING & OPERATION 2.3.1. STARTING ENGINE2.3.3 STARTING MOWER BLADE Section 2 - OPERATING INSTRUCTIONS2.3 STARTING & OPERATION Continued 2.3.2. STARTING WHEEL DRIVE 2.4 STOPPING ENGINE, BLADE, WHEEL DRIVE 2.4.1 STOPPING ENGINESection 2 - OPERATING INSTRUCTIONS 2.4 STOPPING 2.4.3. STOPPING MOWER BLADESSection 2 - OPERATING INSTRUCTIONS 2.6. ROLLING TRACTOR WITH ENGINE OFF Rolling Hydro Models3.1 INTRODUCTION Section 3 - MAINTENANCE3.2 SERVICE - AFTER FIRST 5 HOURS 3.2.1. CHANGE ENGINE OILSection 3 - MAINTENANCE 3.2.4. CHECK DECK DRIVE BELT3. Clutch/Brake Pivot Section 3 - MAINTENANCE3.3.4. TRACTOR LUBRICATION Continued From Previous Page 4. Steering Sector Gear3.4.1. ENGINE Section 3 - MAINTENANCE3.4 ANNUALLY END OF EACH SEASON 3.4.2. FUEL FILTERSection 4 - ADJUSTMENT & REPAIR Section 4 - ADJUSTMENT & REPAIR 2. Move sector plate as required to raise or lower the rear of deckFRONT LIFT Section 4 - ADJUSTMENT & REPAIRPLACE THREE 2 X 4 UNDER FRONT AND REAR OF DECK FRONT LIFT ARMREMOVE WASHER & HAIR PIN ROTATE SWIVEL UP OR DOWN SWIVEL FRONT LIFT Section 4 - ADJUSTMENT & REPAIRREAR LIFT ROD REMOVE WASHER & HAIR PIN ROTATE SWIVEL UP OR DOWN RODDECK BRACKETSWIVELSection 4 - ADJUSTMENT & REPAIR To be properly adjusted, the brake should stopSection 4 - ADJUSTMENT & REPAIR 4.3.3. SHIFTER ADJUSTMENT Continued from pageDANGEROUS CONDITION DO NOT USE ON MOWER Section 4 - ADJUSTMENT & REPAIRNEW BLADE WEAR LIMIT. CRACKS OR NOTCHES BEGIN TO APPEAR 22º TO 28º STANDARD BLADESection 4 - ADJUSTMENT & REPAIR DECK/DRIVESection 4 - ADJUSTMENT & REPAIR 2. Turn engine “OFF”. Remove key 3. Lower the deck to lowest settingSection 4 - ADJUSTMENT & REPAIR 10. Make note of hole used in sector platesSection 4 - ADJUSTMENT & REPAIR VIEW FROM UNDERNEATH TRACTOR Section 4 - ADJUSTMENT & REPAIRTraction drive belt replacement 42” DECK SHOWNSection 4 - ADJUSTMENT & REPAIR 1. Place tractor on a firm level surfaceSection 4 - ADJUSTMENT & REPAIR Section 4 - ADJUSTMENT & REPAIR REMOVE ADJUSTING KNOBS AND MOVE SEAT FORWARDREMOVE POSITIVE + CABLE LAST REMOVE NEGATIVE CABLE FIRST Section 4 - ADJUSTMENT & REPAIR 4.5.5. BATTERY TESTINGSection 4 - ADJUSTMENT & REPAIR 2. Remove spindle pulley from spindle shaftACCESSORIES Section 4 - ADJUSTMENT & REPAIRAVAILABLE ACCESSORIES AVAILABLESECTION 5 - ELECTRICAL SYSTEM MODEL - LT160H42FBVMODELS - LT160H42FBV2 & LT180H48FBV2 SECTION 5 - ELECTRICAL SYSTEMPROBABLE CAUSE TROUBLESHOOTING GUIDEPROBLEM CORRECTIVE ACTIONTROUBLESHOOTING GUIDE TRACTOR MAINTENANCE SCHEDULEMAINTENANCE PARTS DRIVE BELTS3 YEAR LIMITED WARRANTY PRIMARY MAINTENANCE PRIMARY MAINTENANCE PRIMARY MAINTENANCE PRIMARY MAINTENANCE SERVICE NOTES Safety Instructions & Operator’s Manual for Snapper products are built using engines that meet or exceed all applicable emissions requirements on the date manufactured. The labels on those engines contain very important emissions information and critical safety warnings. Read, Understand, and Follow all warnings and instructions in this manual, the engine manual, and on the machine, engine and attachments. If you have any questions about your Snapper product, contact your local authorized Snapper dealer or contact Snapper Customer Service at Snapper, McDonough, GA. 30253. PhoneLAWN TRACTOR HYDROSTATIC DRIVE ELECTRIC CLUTCH SERIES F