Manuals / Snapper / Lawn and Garden / Lawn Mower

Snapper LT160H42FBV2, LT180H48FBV2 Electrical System, MODEL - LT160H42FBV

Models: LT160H42FBV LT180H48FBV2 LT160H42FBV2

1 44

Download 44 pages 46.28 Kb

Page 33

SECTION 5 - ELECTRICAL SYSTEM

SECTION 5 - ELECTRICAL SYSTEM

MODEL – LT160H42FBV

FIGURE 5.1

33

Image 33

Snapper LT160H42FBV2, LT180H48FBV2 important safety instructions Electrical System, MODEL - LT160H42FBV

Contents

LAWN TRACTOR HYDROSTATIC DRIVE ELECTRIC CLUTCH SERIES F Safety Instructions & Operator’s Manual forMODELS LT160H42FBV LT160H42FBV2 LT180H48FBV2PROTECTION FOR CHILDREN IMPORTANT SAFETY INSTRUCTIONSPROTECTION AGAINST TIPOVERS PREPARATIONOPERATION MAINTENANCEIMPORTANT SAFETY INSTRUCTIONS PREPARATIONTABLE OF CONTENTS IMPORTANT SAFETY INSTRUCTIONSTROUBLESHOOTING GUIDE Section 1 - FAMILIARIZATION COMPONENTSCONTROLS Section 2 - OPERATING INSTRUCTIONS 2.1 PRE-START CHECKLIST2.2 OPERATOR’S SEAT ADJUSTMENT 2.2.1. FRONT TO REAR ADJUSTMENT 2.3 STARTING & OPERATION 2.3.1. STARTING ENGINE Section 2 - OPERATING INSTRUCTIONS2.3 STARTING & OPERATION Continued 2.3.2. STARTING WHEEL DRIVE Section 2 - OPERATING INSTRUCTIONS2.3.3 STARTING MOWER BLADE 2.4 STOPPING ENGINE, BLADE, WHEEL DRIVE 2.4.1 STOPPING ENGINE2.4 STOPPING 2.4.3. STOPPING MOWER BLADES Section 2 - OPERATING INSTRUCTIONS2.6. ROLLING TRACTOR WITH ENGINE OFF Rolling Hydro Models Section 2 - OPERATING INSTRUCTIONS3.2 SERVICE - AFTER FIRST 5 HOURS Section 3 - MAINTENANCE3.1 INTRODUCTION 3.2.1. CHANGE ENGINE OIL3.2.4. CHECK DECK DRIVE BELT Section 3 - MAINTENANCE3.3.4. TRACTOR LUBRICATION Continued From Previous Page Section 3 - MAINTENANCE3. Clutch/Brake Pivot 4. Steering Sector Gear3.4 ANNUALLY END OF EACH SEASON Section 3 - MAINTENANCE3.4.1. ENGINE 3.4.2. FUEL FILTERSection 4 - ADJUSTMENT & REPAIR 2. Move sector plate as required to raise or lower the rear of deck Section 4 - ADJUSTMENT & REPAIRPLACE THREE 2 X 4 UNDER FRONT AND REAR OF DECK Section 4 - ADJUSTMENT & REPAIRFRONT LIFT FRONT LIFT ARMREAR LIFT ROD REMOVE WASHER & HAIR PIN ROTATE SWIVEL UP OR DOWN Section 4 - ADJUSTMENT & REPAIRREMOVE WASHER & HAIR PIN ROTATE SWIVEL UP OR DOWN SWIVEL FRONT LIFT RODDECK BRACKETSWIVELTo be properly adjusted, the brake should stop Section 4 - ADJUSTMENT & REPAIR4.3.3. SHIFTER ADJUSTMENT Continued from page Section 4 - ADJUSTMENT & REPAIRNEW BLADE WEAR LIMIT. CRACKS OR NOTCHES BEGIN TO APPEAR Section 4 - ADJUSTMENT & REPAIRDANGEROUS CONDITION DO NOT USE ON MOWER 22º TO 28º STANDARD BLADEDECK/DRIVE Section 4 - ADJUSTMENT & REPAIR2. Turn engine “OFF”. Remove key 3. Lower the deck to lowest setting Section 4 - ADJUSTMENT & REPAIR10. Make note of hole used in sector plates Section 4 - ADJUSTMENT & REPAIRSection 4 - ADJUSTMENT & REPAIR Traction drive belt replacement Section 4 - ADJUSTMENT & REPAIRVIEW FROM UNDERNEATH TRACTOR 42” DECK SHOWN1. Place tractor on a firm level surface Section 4 - ADJUSTMENT & REPAIRSection 4 - ADJUSTMENT & REPAIR Section 4 - ADJUSTMENT & REPAIR REMOVE ADJUSTING KNOBS AND MOVE SEAT FORWARDREMOVE POSITIVE + CABLE LAST REMOVE NEGATIVE CABLE FIRST 4.5.5. BATTERY TESTING Section 4 - ADJUSTMENT & REPAIR2. Remove spindle pulley from spindle shaft Section 4 - ADJUSTMENT & REPAIRAVAILABLE ACCESSORIES Section 4 - ADJUSTMENT & REPAIRACCESSORIES AVAILABLEMODEL - LT160H42FBV SECTION 5 - ELECTRICAL SYSTEMSECTION 5 - ELECTRICAL SYSTEM MODELS - LT160H42FBV2 & LT180H48FBV2PROBLEM TROUBLESHOOTING GUIDEPROBABLE CAUSE CORRECTIVE ACTIONTROUBLESHOOTING GUIDE MAINTENANCE PARTS MAINTENANCE SCHEDULETRACTOR DRIVE BELTS3 YEAR LIMITED WARRANTY PRIMARY MAINTENANCE PRIMARY MAINTENANCE PRIMARY MAINTENANCE PRIMARY MAINTENANCE SERVICE NOTES Safety Instructions & Operator’s Manual for Snapper products are built using engines that meet or exceed all applicable emissions requirements on the date manufactured. The labels on those engines contain very important emissions information and critical safety warnings. Read, Understand, and Follow all warnings and instructions in this manual, the engine manual, and on the machine, engine and attachments. If you have any questions about your Snapper product, contact your local authorized Snapper dealer or contact Snapper Customer Service at Snapper, McDonough, GA. 30253. PhoneLAWN TRACTOR HYDROSTATIC DRIVE ELECTRIC CLUTCH SERIES F