Southbend SSB-45 Adjustment Of Broiler Burners, Adjustment Of Gas Pressure Regulator, Parts

RADIANT STEAKHOUSE BROILER

ADJUSTMENT OF BROILER BURNERS

The burners are adjusted at the factory. Adjustment may be required to achieve proper operation due to elevation change or other variables. Remove the burner cover to adjust the air shutter on each burner venturi (shown in Figure 6 on the previous page) to achieve proper combustion and optimum burn.

ADJUSTMENT OF GAS PRESSURE REGULATOR

The pressure regulator is located at the rear right lower corner of the broiler. The regulator is preset for 6" W.C. for natural gas, or 10" W.C. for propane gas. If adjustment is necessary, do the following:

1.Turn the broiler control knobs to OFF.

2.Attach a pressure-measuring device to the 1/8" NPT connector located on the main manifold (accessible by removing the grease drawer).

3.Turn the broiler control knobs to HIGH. With the burners lit, check the manifold pressure. The pressure should be 6" W.C. (for natural gas) or 10" W.C. (for propane gas).

4.If necessary, adjust the pressure by unscrewing the top of the pressure regulator (use a screwdriver) to expose the adjustment screw underneath. Rotating the adjustment screw clockwise increases the manifold pressure.

5.After the pressure has been adjusted, turn the broiler control knobs to OFF, and replace the top cap of the pressure regulator. Disconnect the pressure-measuring device and replace the plug into the manifold.

PARTS

The following table describes the serviceable parts. For parts not listed, contact a Southbend Authorized Parts Distributor or a Southbend Authorized Service Agency.

PARTS LIST	NATURAL GAS		Quantity
Part Number	DESCRIPTION	SSB-32	SSB-36	SSB-45
1006436	BURNER ORIFICE	2	2	3
1176008	BURNER VALVE	2	2	3
1184384	PILOT ADJUST	1	1	1
1167782	REGULATOR,PRESS,WC @ 6",NAT	1	1	1
1130399	BURNER, HI-GLOW	2	2	3
1130398	VENTURI ASSEMBLY, HI-GLOW	2	2	3
1-5371	CERAMIC TILE	20	20	30
1189600	KNOB	2	2	3

PARTS LIST	PROPANE GAS		Quantity
Part Number	DESCRIPTION	SSB-32	SSB-36	SSB-45
1006451	BURNER ORIFICE	2	2	3
1176009	BURNER VALVE	2	2	3
1184384	PILOT ADJUST	1	1	1
1167783	REGULATOR,PRESS,WC @10",PROP	1	1	1
1130399	BURNER, HI-GLOW	2	2	3
1130398	VENTURI ASSEMBLY, HI-GLOW	2	2	3
1-5371	CERAMIC TILE	20	20	30
1189600	KNOB	2	2	3

PAGE 18 OF 20 OWNER’S MANUAL 1190950 (02/09)