Southbend STRE-3D Wiring Diagram for 208/220/240 Volt Models

STRATOSTEAM COUNTERTOP STEAMER SERVICE

OWNER’S MANUAL 1185184 PAGE 33 OF 48

Figure 22

Wiring Diagram for 208/220/240 Volt Models

KEY

THIS UNIT REQUIRESA KITTO BE FIELD CONVERTEDFROM THREE-PHASETOSINGLE-PHASE OR VICE-VERSA. CONSULTFACTORY

WARNING

FOR PHASE CHANGES.NOTE: a. ALL STRE-3D ELEMENTS ARE 1500 W EACH b. ALL STRE-5D ELEMENTS ARE 1834 W EACH

POWER MICROSWITCH

HEATER T'STATS

"POWER" LIGHT

POWER MICROSWITCH

8,13

TIMER

SWITCH

COM NC

BUZZER

THERMOSTAT

DOOR SWITCH

COM NC

CONTACTOR COIL

(NC)

3 PHASE

CENTER

L2L1 L3

CONTACTOR

WATER SOL COIL

L1 L2

1,13

2,6

5,7

11,12

10,11

11 51

Contents

Main Owners Manual StratoSteam Model STRE-3D Model STRE-5D Countertop Steamer Models STRE-3D and STRE-5D SAFETY PRECAUTIONS INTRODUCTION Location of Serial Plates SPECIFICATIONS NOTICE CLEARANCES WARNING MINIMUM CLEARANCES FROM COMBUSTIBLE CONSTRUCTION DIMENSIONS Dimensions ELECTRICAL REQUIREMENTS WATER REQUIREMENTS DRAIN REQUIREMENTS OPERATION NOTICE: WATER SPECIFICATION STARTUP OPERATION CAUTION Control Lever Timer Power Light Thermometer COOKING TIPS SUGGESTED COOKING TIMES CLEANING & MAINTENANCE DAILY CLEANING AND MAINTENANCE PERIODIC DE-LIMING (AS NEEDED) STAINLESS-STEEL SURFACES Page INSTALLATION CAUTION NOTICE STEP 1: UNPACKING IMMEDIATELY INSPECT FOR SHIPPING DAMAGE STEP 2A: ATTACH LEGS Attach Legs STEP 2B: ATTACH TO COUNTERTOP Installation on Countertop STEP 2C: MOUNTING ON CABINET BASE STEP 2D: STACKING TWO STEAMERS Location of Connections and Vents STEP 3: DRAIN CONNECTION Water Drain STEP 4: WATER CONNECTION WARNING NOTICE Water Connection STEP 5: ELECTRICAL CONNECTION WARNING Electrical Connection STEP 6: CHECK THE INSTALLATION STEP 7: CHECK STEAMER OPERATION STEP 8: SHUT-DOWN AND WIPE-CLEAN STEAMER SERVICE TROUBLESHOOTING FLOWCHARTS, PROCEDURES, AND WIRING DIAGRAMS HOW THE STEAMER OPERATES How the Steamer Operates P AGE 22 OF 48 OWNER S M Steamer Not Heating Up, Power Light Is Not Lit Steamer Not Heating Up Properly or Not Cooking Properly, Power Light is Lit P AGE 24 OF 48 OWNER S M Buzzer Does Not Come On When Timer Runs Out STRATOSTEAM COUNTERTOP STEAMER SERVICE Heating Cartridge Check (at Contactor) Top of Steamer Power Switch Check Contactor Check Timer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water-Level-Control Sensor Check Water Solenoid Check OWNERS MANUAL 1185184 PAGE 33 OF 48 Figure 22 FOR PHASE CHANGES. Wiring Diagram for 208/220/240 Volt Models WARNING NOTE: a. ALL STRE-3D ELEMENTS ARE 1500 W EACH b. ALL STRE-5D ELEMENTS ARE 1834 W EACH P AGE 34 OF 48 OWNER S M Wiring Diagram for 480 Volt Models WARNING NOTE: a. ALL STRE-3D ELEMENTS ARE 1500 W EACH b. ALL STRE-5D ELEMENTS ARE 1834 W EACH PARTS Page Structural Parts Door Assembly Parts Door Switch Parts Control Panel Parts Heating Cartridges, Thermostats, and Contactor Parts Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Page Page StratoSteam Countertop Steamer Models STRE-3D and STRE-5D