Please Read and Save These Instructions
For Safety, Read All Safety and Operation
Operator’s Manual
Beginning S/N:
Foreword
DIMENSIONS Tractor and Mower
Table of Contents
Assembly Instructions______________
SAFETY, CONTROL, AND
MAINTENANCE SCHEDULE CHART________
Maintenance Instructions___________
Warranty______________________
Engine Air Cleaner System_ _____________
GLOSSARY
General Information
HIGHLIGHTED INFORMATION
IDENTIFYING NUMBER LOCATIONS
ENGINE SERIAL NUMBER LOCATION
Tractor Serial Number Location
Mower Deck Serial Number Location
Engine Serial Number Location
ENGINE
Specifications
MODEL
ELECTRICAL SYSTEM
Ground Travel Speed
TRANSMISSION continued
Transmission Fluid
BLADE DRIVE
MODELS14
DIMENSIONS Tractor and Mower Length in. cm
Weight lb kg
Width in. cm
SEAT
MOWER DECK
DRIVE BELTS
FRAME/BODY CONSTRUCTION
Instructions section
Component Identification
in Operating
Front View and Right Side View
Rear View and Left Side View
Component Identification
Top View Body Raised
Component Identification
BEFORE OPERATING
Safety Instructions - Before Operating
DANGER
Do not mow with bystanders in the area
Safety Instructions - Before Operating
a.Use an approved fuel container
Safety Instructions - Operating
DANGER
DANGER
Safety Instructions - Operating
a.Do not move tractor with deck in tilt-upposition
Safety Instructions - Maintenance
Part Number:
SAFETY, CONTROL, AND INSTRUCTION DECALS
Safety Instructions
Location: Rear of Grass Catcher Exhaust Screen
1 Location Deck Carrier Frame Part Number
Location: Each End of Mower Deck Part Number:
Location: Deck Carrier Frame Part Number:
Location: Top of Fuel Tank Part Number: 1
SAFETY, CONTROL, AND INSTRUCTION DECALS
7 8 Location: LH Fender Part Number:
4 5 Location: RH Fender Part Number:
Safety Instructions
Tire Installation Tractor
Assembly Instructions
SETUP INSTRUCTIONS
Battery Service
Deck Caster Wheels Installation
Battery Installation
Battery Installation Mower Deck Assembly
BATTERIES PRODUCE EXPLOSIVE GASES
Discharge Shield Installation
Deck Caster Wheel Installation
Deck Discharge Deflector Shield Installation
PTO Shaft Guard Installation
Deck Installation
Installation on Rear Discharge Deck
Mower Deck Installation on Tractor
Mower Deck Installation
Deck Leveling
Deck Leveling
Assembly Instructions
in Maintenance Instructions
PREOPERATING CHECKLIST
Maintenance Instructions
•DO NOT fill fuel tank with the engine run- ning
Assembly Instructions
Blades in Maintenance Instructions
Deck Secured in TILT-UPPosition
DANGER
Operating Instructions
Ignition Switch
Ignition Switch Key Positions
CONTROL IDENTIFICATION, LOCATION, AND FUNCTION
Forward Speed Control FSC
Engine Throttle
Choke and Throttle Location
Front Body Latch Release
Transaxle Lockout Arms
Parking Brake
Parking Brake Engaged Parking Brake Disengaged
Hydro Lockout Arm Location
Hourmeter
Operating Instructions
Hourmeter
Operating Instructions
LEFT WHEEL STEERING LEVERRIGHT WHEEL
ENGAGED
ADJUSTING GROUND SPEED AND STEERING
STARTING THE ENGINE
Operating Instructions
Beginning Recommendations are
Forward Speed Control Friction Adjustment in
the Maintenance Instructions
BEFORE operating on slopes
ENGAGING THE BLADE DRIVE
Correct Operator Hand Position on the Controls
Instructions
Operating Instructions
STOPPING THE MACHINE
Blade Clutch Engaged
Blade Clutch Disengaged
Operating Instructions
Hydro Lockout Arm - Freewheel Position
ADJUSTING CUTTING HEIGHT
Cutting Height Adjustment TRANSAXLE LOCKOUTS
Hydro Lockout Arm - Normal Operating Position
Operating Instructions
RECOMMENDATIONS FOR MOWING
Avoid Low Hanging Branches
DANGER
Maximum Recommended Slope
Side Discharge Deflector Shield in
Lowest Position
No Driving Zone
Operating Instructions
GHS Flow and Components
GRASS HANDLING SYSTEM GHS
GHS Model Only
Operating Instructions
Operating Instructions
General Information
ROTATING BLOWER BLADES
DANGER
Blade Rotation for Standard Rotation
Clogging Checklist
FORWARD
GHS Mower Deck Bottom View
Powerfil
Using the Tilt-UpDeck
Using the GHS Catcher
“Full” Signal Horn
Dumping the Catcher
Cleaning the GHS Exhaust Screen
Grass Catcher Screen Removal for Cleaning
Tailgate Dumping
Dumping Catcher into Dump Bag
Using the Dump Bag
Positioning Dump Bag on Catcher
Operating Instructions
Every
Maintenance Instructions
Service Item
Hours
IMPORTANT TIPS FOR CARE OF THE SUBARU ENGINE
Air Cleaner System
SUBARU TIPS
Fuel System
Engine Oil
LUBRICATION
LUBRICATION
Engine Break-InOil
View from Lower Right Side of Tractor
Changing Engine Crankcase Oil
Oil Drain Location
Dipstick Oil Fill Location
Maintenance Instructions
Deck and Carrier Frame Illustrated
Parts Manual
LUBRICATION
Chassis and Deck Lubrication Points DC36R Shown
Maintenance Instructions
LUBRICATION
23 &
Removed for Clarity
Mower Deck Gearbox Lubrication
Mower Deck Gearboxes Shown with Gearbox Cover
Mower Deck Spindle Lubrication
Guard Location Shown with Deck Support Arms
Transaxle Oil and Filter Change
Transaxle Oil Drain Plug, Filter, and
Maintenance Instructions
Engine Air Cleaner System
CLEANING
CLEANING
Donaldson Radialseal Air Cleaner
Air Filter Element Replacement
Maintenance Instructions
CLEANING
Fuel Filter and Fuel Shut-offValve Location
Proper Orientation of Air Cleaner Cover
Fuel Filter
•Use an approved fuel container for gas- oline
Engine Cooling System
Air Intake Screen Clean
Inspect and Clean Cylinder Head Cooling Fins
Cooling Air Intake Screen
GHS Exhaust Screen
Grass Buildup in Mower Deck Housing
GHS Blower
Maintenance Instructions
Transaxle Housing and Cooling Fins
CLEANING CHECKING/SERVICING
Transaxle Housing
Battery
CHECKING/SERVICING
Cleaning the Terminals
Charging the Battery
Tire Pressure
Maintenance Instructions
Mower Blade Profile for Sharpening
Blade Balanced on Magnetic Wall-MountedBalancer
CHECKING/SERVICING
Spark Plug
Drive Belts
Mower Deck Gearbox Oil Seals
Ignition
Maintenance Instructions
Safety Switch System
Forward Speed Control Friction Lock
CHECKING/SERVICING
Belt Locations
REPLACING/REPAIRING
REPLACING/REPAIRING
Maintenance Instructions
Engine Belt Engaged
Engine Belt
Engine Belt Disengaged
Maintenance Instructions
PTO Drive Belt Engaged
PTO Drive Belt
PTO Drive Belt Disengaged
Maintenance Instructions
Ground Drive Belt
Ground Drive Belt Assembly Disengaged
Ground Drive Belt Assembly Engaged
Maintenance Instructions
PTO Shear Pin If Equipped
Blade Overload Shear Bolts
Cutting Blade Shear Bolts
PTO Shear Pin
REPLACING/REPAIRING
Mower Blades
Maintenance Instructions
DANGER
Step 1 - Steering Lever Position Adjustment
ADJUSTMENTS
ADJUSTMENTS Transmission Control
Lever Alignment
Step 3 - Neutral Position Adjustment
Step 2 - Steering Handles Adjustment
Steering Handles Adjustment
FSC Lever Position Adjustment
Front Body Hidden for Clarity
Tracking Adjustment Components
Transmission Control Rod and Arm Location
Maintenance Instructions
Step 6 - FSC Neutral Switch Adjustment
Step 4 - Full Forward Speed Adjustment
Step 5 - Straight Tracking Adjustment
FSC Neutral Switch Location
FSC Friction Adjustment Nut
FSC Neutral Switch Adjustment
FSC Friction Adjustment Test
Side View Through Chassis
Maintenance Instructions
Clutch Engagement/Belt Tension
PTO Clutch Engaged
ADJUSTMENTS
Maintenance Instructions
Blade Brake Band Adjustment
PTO Clutch Disengaged
ADJUSTMENTS
Maintenance Instructions
Tilt-UpDeck Adjustable Stop
Blade Brake Band Adjustment Clutch Disengaged
ADJUSTMENTS
powerful, and the door can slam shut with
GHS “Full” Signal Horn Adjustment
When lowering the door on the GHS
Adjusting the Grass-Pak Switch
Operator’s Notes
Operator’s Notes
2.WHAT THIS WARRANTY DOES NOT COVER
LIMITED WARRANTY FOR WALKER MODEL S14 RIDER MOWER
1.WHAT THIS WARRANTY COVERS, AND FOR HOW LONG
3.HOW TO OBTAIN SERVICE UNDER THIS WARRANTY
FORM NO.
PRINTED IN USA
2014 WALKER MFG. CO