Contents
Liquid-cooled, Prepackaged Standby Generators
Introduction
Authorized Service Dealer Location
Operation and Maintenance
HOW to Obtain Service
Introduction IFC Safety Rules
General Hazards
Electrical Hazards
Generator AC Connection Systems
Transfer Switch
Generator
Automatic System Operation
Engine Protective Devices
1.7.1 LOW OIL Pressure Switch
1.7.2 High Coolant Temperature Switch
1.7.3 LOW Coolant Level Switch
Lifting the Generator
Unpacking
1.10.2 Engine Specifications
Specifications
Reconfiguring the Fuel System
1.10.1 Generator Specifications
Torque Specifications
Engine OIL Recommendations
Coolant Recommendations
2.1.1 Nfpa Standards
Generator Mounting Support
Basic Standby Electric System
Generator Location
Grounding the Generator
Transfer Switch Start Signal Connections
Emergency Circuit Isolation Method
Total Circuit Isolation Method
2.11.1 Prior to Initial START-UP
Battery Installation
Preparation Before START-UP
2.10.1 Vented Batteries
Control Console Components
Using a Standard GTS Transfer Switch
Weekly Exercise Cycle
Manual Transfer START-UP Automatic Operation
Engine Heater
Cooling System
Overload Protection for Engine DC Electrical System
Checking Fluid Levels
4.5.6 Perform Visual Inspection
4.5.11 Changing the Engine AIR Cleaner
4.5.4 Inspect Cooling System
4.5.5 Check Engine Coolant Level
4.5.13 Coolant Change
Miscellaneous Maintenance
4.6.4 Battery Replacement
4.6.3 Battery Maintenance
Service Maintenance Interval Information
Scheduled Maintenance
Level
Maintenance Level
Problem Cause Correction
Troubleshooting Points
Guardian Liquid-cooled 15 kW, 20 kW and 25 kW Generators
Guardian Liquid-cooled 15 kW, 20 kW and 25 kW Generators
Installation Diagram
Section
DC-VR
Customer Connection 120/240V 1-PHASE
Electrical Data
ASM Motor Stepper
Housing Governor Connector
Connector Interface Assembly
Cover Connector Housing
Washer Flat 5/16 Zinc
BASE,MOUNTING 1.5L STNRD&ACSTC
Washer Shakeproof EXT 5/16 STL
Dampener Vibration
Roof Cover Cable Weld Stud Under
Roof ACSTC&STND Cmprtmnt 1.5L
Assembly BASE-DOOR Ground Wire
GRD Wire Assy 99HSB
Assembly Cover Access
Weld Stud Under Roof Panel for Access Cover Cable
BRACE, Side 1.5L Mitsu
ASSEMBLY,BASE-DOOR Ground Wire
ROOF, ACSTC&STND Cmprtmnt 1.5L
SUPPORT, Radiator 1.5L Mitsu
To a
Silksc
Wire Assembly
Screw Hhtt M5-0.8 X 12 BP
Washer Flat #10 Zinc
Hardware
ENGINE-1.5L
Switch OIL Pressure
ARM Adjust Alternator
Ground Wire Starter
16 7
Guard FAN 1.5L Modine
Tank Coolant Recovery
Radiator 1.5L
Venturi 1.5L Modine
Vapor
Flange Fuel Inlet
Cover AIR Cleaner
GASKET, AIR Cleaner Adapter
Weldment Mounting Base
To Engine Crankshaft
Assy Rotor 20KW
Housing Blower
Assy Rotor 10KW
Assy Rotor 15KW
Battery Post Cover RED+
ASSY,WIRE#16 RED
BOOT, Battery Cable
BRACKET, Battery Hold Down
PIPE,EXHAUST 1.5L STNDRD&ACSTC
Manifold Exhaust 1.5L
Nipple TOE 1.5NPTX5.5 BLK Iron
Saddle 2 Inch
Your Warranty Rights and Obligations
MANUFACTURER’S Emission Control System Warranty Coverage
PURCHASER’S/OWNER’S Warranty Responsibilities
Emission Related Parts Include the Following
Emission Control System Warranty
This Warranty Shall not Apply to the Following
Warranty Schedule