Contents
Liquid-cooled, Prepackaged Standby Generators
Operation and Maintenance
Authorized Service Dealer Location
HOW to Obtain Service
Introduction
Introduction IFC Safety Rules
General Hazards
Electrical Hazards
Generator
Transfer Switch
Automatic System Operation
Generator AC Connection Systems
1.7.2 High Coolant Temperature Switch
1.7.1 LOW OIL Pressure Switch
1.7.3 LOW Coolant Level Switch
Engine Protective Devices
Lifting the Generator
Unpacking
Reconfiguring the Fuel System
Specifications
1.10.1 Generator Specifications
1.10.2 Engine Specifications
Coolant Recommendations
Torque Specifications
Engine OIL Recommendations
Basic Standby Electric System
Generator Mounting Support
Generator Location
2.1.1 Nfpa Standards
Emergency Circuit Isolation Method
Transfer Switch Start Signal Connections
Total Circuit Isolation Method
Grounding the Generator
Preparation Before START-UP
Battery Installation
2.10.1 Vented Batteries
2.11.1 Prior to Initial START-UP
Control Console Components
Using a Standard GTS Transfer Switch
Weekly Exercise Cycle
Manual Transfer START-UP Automatic Operation
Engine Heater
Checking Fluid Levels
Cooling System
Overload Protection for Engine DC Electrical System
4.5.4 Inspect Cooling System
4.5.11 Changing the Engine AIR Cleaner
4.5.5 Check Engine Coolant Level
4.5.6 Perform Visual Inspection
4.5.13 Coolant Change
Miscellaneous Maintenance
4.6.4 Battery Replacement
4.6.3 Battery Maintenance
Service Maintenance Interval Information
Scheduled Maintenance
Level
Maintenance Level
Problem Cause Correction
Troubleshooting Points
Guardian Liquid-cooled 15 kW, 20 kW and 25 kW Generators
Guardian Liquid-cooled 15 kW, 20 kW and 25 kW Generators
Installation Diagram
Section
DC-VR
Customer Connection 120/240V 1-PHASE
Electrical Data
Connector Interface Assembly
Housing Governor Connector
Cover Connector Housing
ASM Motor Stepper
Washer Shakeproof EXT 5/16 STL
BASE,MOUNTING 1.5L STNRD&ACSTC
Dampener Vibration
Washer Flat 5/16 Zinc
Roof Cover Cable Weld Stud Under
GRD Wire Assy 99HSB
Assembly BASE-DOOR Ground Wire
Assembly Cover Access
Roof ACSTC&STND Cmprtmnt 1.5L
Weld Stud Under Roof Panel for Access Cover Cable
ROOF, ACSTC&STND Cmprtmnt 1.5L
ASSEMBLY,BASE-DOOR Ground Wire
SUPPORT, Radiator 1.5L Mitsu
BRACE, Side 1.5L Mitsu
To a
Screw Hhtt M5-0.8 X 12 BP
Wire Assembly
Washer Flat #10 Zinc
Silksc
Hardware
ARM Adjust Alternator
Switch OIL Pressure
Ground Wire Starter
ENGINE-1.5L
16 7
Radiator 1.5L
Tank Coolant Recovery
Venturi 1.5L Modine
Guard FAN 1.5L Modine
Vapor
GASKET, AIR Cleaner Adapter
Cover AIR Cleaner
Weldment Mounting Base
Flange Fuel Inlet
To Engine Crankshaft
Assy Rotor 10KW
Housing Blower
Assy Rotor 15KW
Assy Rotor 20KW
BOOT, Battery Cable
ASSY,WIRE#16 RED
BRACKET, Battery Hold Down
Battery Post Cover RED+
Nipple TOE 1.5NPTX5.5 BLK Iron
Manifold Exhaust 1.5L
Saddle 2 Inch
PIPE,EXHAUST 1.5L STNDRD&ACSTC
PURCHASER’S/OWNER’S Warranty Responsibilities
Your Warranty Rights and Obligations
MANUFACTURER’S Emission Control System Warranty Coverage
Emission Related Parts Include the Following
Emission Control System Warranty
This Warranty Shall not Apply to the Following
Warranty Schedule