Generac 004702-0, 004703-0, 004704-0, 004705-0, 004706-0, 004707-0 Battery Installation

Page 34

Section 6 – Installation

QUIETPACT 55, 65, and 75 Recreational Vehicle Generators

◆6.7.7 GROUND FAULT CIRCUIT INTERRUPTERS

The National Electrical Code (NFPA 70, article 551) requires that you install ground fault circuit inter- rupters (GFCIs) on all external and some internal electrical receptacles. Contact your manufacturer or dealer for recommendations.

6.8BATTERY INSTALLATION

◆6.8.1 RECOMMENDED BATTERY

Install a battery that meets the following require- ments:

•The battery must be a 12-volt, automotive type storage battery.

•For prevailing ambient temperatures above 32° F (0° C), use a battery rated 70 amp-hours and capa- ble of delivering 400 cold-cranking amperes.

•For prevailing ambient temperatures below 32° F (0° C), use a battery rated 95 amp-hours and capa- ble of delivering 400 cold-cranking amperes.

NOTE:

If the battery is to be used to power other vehicle accessories, as well as start the generator, you may need a battery with a larger capacity.

◆6.8.2 BATTERY CABLES

Using battery cables that are too long or too small in diameter may cause a drop in voltage, which causes starting problems. For the best cold weather starting, the voltage drop between battery terminals and the generator connection point should not exceed 0.12 volts per 100 amperes of cranking current.

PRIMEPACT generators are rated at about 100 DC amperes of cranking current.

Select battery cables based on (a) cable length and (b) prevailing ambient temperatures. Generally, the longer the cable and the colder the weather, the larg- er the cable size must be, as shown in the chart.

 

CABLE LENGTH

 

 

 

in Feet (meters)

CABLE SIZE

 

 

0 to 10 (0 to 3)

2*

 

 

11 to 15 (3.4 to 4.5)

0

 

 

16 to 20 (4.5 to 6)

000

 

 

 

 

 

*For warm weather, use No. 2 cable up to 20 feet.

◆6.8.3 BATTERY CABLE CONNECTIONS

1.Connect the battery cable from the battery post or terminal indicated by a POSITIVE, POS or (+) to the lug on the starter contactor (Figure 6.21).

NOTE:

Check to be sure the battery cable boot for the starter cable has been installed.

2.Connect the battery cable from the battery post indicated by a NEGATIVE, NEG or (-) to the frame ground connection (Figure 6.21).

3.Connect cables so the connectors are clean and tight.

Figure 6.21 – Connecting Battery Cables

Positive Cable

— +

Battery

Negative Cable

Chassis Ground

◆6.8.4 BATTERY COMPARTMENT

Install the generator battery in its own, vented com- partment. Place the battery compartment away from any source of heat, sparks or flame.

Provide ventilation openings in the battery compart- ment. The minimum size of openings should be 2 square inches at the top of the compartment. Mount the battery on a strong, rigid supporting structure, where leaks and spills of battery fluid will not cause damage.

32 Generac® Power Systems, Inc.

Page 33 Page 35
Image 34
Page 33 Page 35
Contents This manual should remain with the unit Authorized Service Dealer Location IntroductionTable of Contents General Hazards Electrical Hazards Generator Identification Reference Number IdentificationGenerator Applicability InstallationSafety Generator AC Connection System1.1 Fuel Consumption gph/lbs.ph SpecificationsFuel Requirements Gasoline Generator Control Panel Automatic Choke Optional Remote START/STOP PanelBefore Starting the Engine Stopping the Generator Starting the GeneratorLetting the Engine Stabilize Protection Systems High Temperature SwitchLOW OIL Pressure Switch Field Boost6 25-HOUR CHECK-UP Checking the Engine OIL LevelOvervoltage Protection 5 25-HOUR BREAK-IN PeriodCleaning the Foam Precleaner Maintaining the Engine AIR CleanerChanging the Engine OIL AND/OR OIL Filter Clean Spark Arrestor Checking the Engine Spark PlugWeekly Cleaning the GeneratorBattery Maintenance Every SIX MonthsDrive Belt OUT of Service ProcedureRV Generator Service Interval Exercising the GeneratorQuietpact 55, 65, and 75 Recreational Vehicle Generators Part General Hazards Electrical Hazards Equipment Description Purpose and Scope Installation InstructionsStandards Booklets Generator Engine Operating SpeedDimensions Drawing No E1058-A Location and Support Generator LocationCompartment Size Generator CompartmentsSuspended Mounting Generator RestraintSound Insulating Materials Typical Compartment ConstructionCompartment Floor Cutouts Cooling and Ventilating AIRAcoustics Generator AirflowTesting the Installation Gasoline Fuel SystemGenerator Fuel Supply Line LP GAS Fuel SystemParts not Included in Fuel System Vapor Withdrawal Primary RegulatorSome Important Considerations Gaseous CarburetionLeakage Tests Exhaust SystemFuel Supply Lines Excess Flow ValveMufflers and Spark Arrestors Exhaust System SafetyElectrical Connections Electrical Junction BOXPower Supply Cord WiringIsolating Different Power Sources Generator AC ConnectionsBattery Cables Battery InstallationRecommended Battery Battery Cable Connections18 Transfer Switch Isolation Method Before Initial START-UP Optional AccessoriesPost Installation Tests Initial StartTesting Under Load Installation ChecklistTroubleshooting Guide Problem Cause CorrectionQuietpact 55, 65, and 75 Recreational Vehicle Generators Battery Supplied by Customer 12V Battery 19 18 Part NO. QTY Description View a QTY Description 105 Screw Hhtt M6-1.0 X 10 YC 28,2 Circuit Breaker 3 X 15A 15B ASSEMBLY, Crankcase RV Exploded Views and Parts Lists CASTING, Twin Regulator Housing MANUFACTURER’S Emission Control System Warranty Coverage Your Warranty Rights and ObligationsPURCHASER’S/OWNER’S Warranty Responsibilities Emission Control System Warranty Emission Related Parts Include the FollowingWarranty Schedule CONSUMER/PERSONAL Applications

004702-0, 004703-0, 004704-0, 004705-0, 004706-0, 004707-0 specifications

Generac has established itself as a leader in the power generation industry, particularly noted for its wide range of generators designed to provide reliable backup power. Among its various models, the Generac series consisting of the 004702-0, 004703-0, 004704-0, 004705-0, 004706-0, and 004707-0 stands out due to their dependable performance and innovative features. Each model in this series is engineered for both residential and light commercial applications, offering peace of mind during power outages.

One of the main features of these models is their state-of-the-art engine technology. Equipped with a Generac engine, these generators are designed to provide efficient, powerful performance. The engines are robust and designed to withstand extended use, ensuring that users can rely on them when needed most.

A standout feature is their Automatic Transfer Switch (ATS) capability. When the power goes out, these generators automatically switch on, providing uninterrupted power to essential appliances and systems in the home. This seamless transition is vital for maintaining safety and comfort during outages, eliminating the need for manual intervention.

Fuel efficiency is another area where these models excel. They utilize either natural gas or propane, offering flexibility in fuel choice depending on availability and preference. Their engineering is optimized for minimal fuel consumption while maximizing output, making them a cost-effective solution for power needs.

Furthermore, these models incorporate advanced monitoring and control systems. Users can conveniently monitor generator performance and status through an intuitive mobile app or control panel. This technology allows users to receive alerts and updates, ensuring they are always informed about the power situation at their location.

Noise reduction technology is also a key characteristic of this series. Generac's engineers have focused on minimizing sound output, providing a quieter operation compared to many other generators in the market. This feature is particularly beneficial for residential areas where noise can be a significant concern.

Overall, the Generac 004702-0, 004703-0, 004704-0, 004705-0, 004706-0, and 004707-0 models exemplify reliability, efficiency, and advanced engineering. Their comprehensive features and user-friendly technology make them an excellent choice for anyone seeking a dependable backup power solution.
Top Page Image Contents