Summit HL-630 OPC manual Samsung SCX-6320Toner/OPC Cartridges, Samsung SF-830 Toner Cartridges

Samsung SCX-6320Toner/OPC

Cartridges

Samsung Cart. # SCX-6320D8 (Toner), SCX-

6320R2 (Drum)

OEM Stated Yield: 8,000, 18,000 respectively

Both of these cartridges use different items to reset the printer. The toner cartridge uses a chip that must be replaced/reset each cycle. There are different manufacturers using this engine. Each manufacturer has it’s own separate chip, even Samsung has different versions. Make sure you have the correct chip for the machine the cartridge will be going into. Reset boxes are available to reset the OEM as well as aftermarket chips. Some reset boxes will also allow the change from one manufacturer to another.

Drum Cartridge: This cartridge uses a fuse to reset the printer. The fuse is located on the gear side of the cartridge. Starter cartridges do not have a fuse, but the holder is there. The fuse must be replaced each cycle. The fuse is a 250V 5 x 20mm 63mA fuse. Make sure you have the correct fuse or printer damage may occur!

changing brands. The resistors are under a small contact plate on the gear side of the cartridge

Sharp AL-1000/Xerox XD-100 Toner

Cartridges

Sharp Cart. # AL-100TD, Xerox Cart. # 6R914

OEM Stated Yield: 6,000

The standard AL-100TD, and 6R914 cartridges are not interchangeable. They have Oblong tabs on the backside of the cartridges that are in different locations. These tabs block the use of one brand in the others machine. They can be made to be interchangeable by cutting off the tabs, and sealing up the hole. See our cartridge recycling instructions for detailed information. These cartridges also do not have any type of reset. There is a sensor inside the cartridge that measures the mixture of toner to developer. As long as there is enough toner for a good mixture level, the toner lamp will stay off. There are no page counters or “Killer Chips” for these cartridges.

There are other versions of these cartridges however that do have “Killer Chips”. The following are the current Sharp AL-1000 Engine based cartridges that also have the chips in them.

Samsung SF-830 Toner Cartridges

Samsung Cart. # SCX-5312D6

OEM Stated Yield: 7,500 These cartridges do not use a chip or any type of reset. They are included here because they use a resistor to tell the machine what brand it is. Samsung cartridges have a 30k Ohm resistor, where Xerox cartridges have a 12k Ohm resistor. If you are getting an “Invalid Cartridge” message, the wrong resistor is installed. These resistors do not go bad, and should never need to be replaced unless you are

Sharp AR-150 Toner

Sharp Cartridge Part # AR-150TD

OEM Stated Yield: 6,000

These cartridges use the same supplies to recycle as the AL-1000 (XD-100) cartridges. The difference is that the oblong tab on the back side if the cartridge is placed differently, and the cartridge has a “killer chip” that shuts the machine down after 10,000

33