Linear SLC, SLD, SLR manual Table of Contents

Table of Contents

Pre-installation Information		.	. .	.	1	Advanced Controller Programming				. . . . .	.	.	.13
	Before You Begin	.	. .	.	1	Entering Advanced Programming Mode		. . . . . . . . . .	.	. . . . . . .	. .	.	.13
	Always Check the Gate’s Action	.	. .	.	1	Maximum Run Time		. . . . . . . . .	.	. . . . . . .	. .	.	.13
	Gate Operator Classifications	.	. .	.	1	Single Button Input Setup		. . . . . . . . .	.	. . . . . . .	. .	.	.13
	Approved Obstruction Detection Devices	.	. .	.	1	Stagger Mode		. . . . . . . . .	.	. . . . . . .	. .	.	.13
Safety Information and Warnings		.	.			Stagger Delay Time				. . . . .	.	.	13
				.1						. . . . .	.	.	.14
	Regulatory Warnings	.	.			Auxiliary Relay Mode
					1								.14
Wiring Specifications					2	Reverse Delay Time		. . . . . . . . .	.	. . . . . . .	. .	.
		.	. .	.		Low Power Mode				. . . . .	.	.	.14
	AC Power Wiring				2
		.	. .	.		Power Failure Mode				. . . . .	.	.	14
	DC Control and Accessory Wiring	.	.
				.2									.15
Mounting Pad Installation			.			Soft Start/Stop Duration		. . . . . . . . .	.	. . . . . . .	. .	.
				.3									.15
	Gate Preparation	.	.			Reset Cycle Count		. . . . . . . . .	.	. . . . . . .	. .	.
					3		Alert Trigger			. . . . .	.	.	15
Gate Bracket and Chain Assembly					4	Maintenance
		.	. .	.		Mid-travel Stop Position				. . . . .	.	.	15
Operator Preparation		.	. .	.	5	Motor Type Selection				. . . . .	.	.	.15
	Vent Plug Installation	.	.			Radio Enable				. . . . .	.	.	.16
					5					. . . . .	.	.	16
Operator Setup					5	Antenna Installation
		.	. .	.		Radio Transmitter Learn							.16
	Controller Access				5			. . . . . . . . .	.	. . . . . . .	. .	.
		.	. .	.		Radio Transmitter Delete				. . . . .	.	.	.16
	AC Power Connection	.	.
				.5									.16
	Earth Ground	.	.			MGT Obstacle Transmitter Learn		. . . . . . . . .	.	. . . . . . .	. .	.
					5					. . . . .	.	.	16
	Limit Nuts Rough Adjustment				6	MGT Obstacle Transmitter Delete
		.	. .	.		Reset Controller to Factory Defaults				. . . . .	.	.	.16
	Limit Nuts Fine Adjustment	.	.	.
					6								.17
Controller Features		.	.	.		Loop Layout Illustration		. . . . . . . . .	.	. . . . . . .	. .	.
					7					. . . . .	.	.	18
Indicator Descriptions			.			Safety Edge Layout Illustration #1
				.8						. . . . .	.	.	19
Terminal Descriptions			.			Safety Edge Layout Illustration #2
				.9
Operator Accessory Connections			.			Photoeye Installation Illustration. . . . . . . . . . . . . . . . . . . . 20
				10				. . . . . . .	. . . . . . . 21
Basic Controller Programming				11		Picket Gate Installation
		..	.. ..			Track Gate Installation							.22
	Programming Overview	.	.					. . . . . . . . .	.	. . . . . . .	. .	.
				11
	Entering Programming Mode	.	. .	11		Dual Gate Installations		. . . . . . . . .	.	. . . . . . .	. .	.	.23
	Exiting Programming Mode	.	.	11				. . . . . .	. . . . . . . . 24
	Programming Keystrokes			11		Gate Operation
		.	. .			Open Button .							.24
	Left or Right Hand Operation.. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. .. ..11							. . . . . . . . .	.	. . . . . . .	. .	.
						Close Button.							.24
	Dual Gate Enable			11				. . . . . . . . .	.	. . . . . . .	. .	.
		. .	. .			Stop Button. .	. . . . . . . . . . . . . . . . . . . . .	. . . . . . . . .	.	. . . . . . .	. .	.	.24
	Auto Close Timer		.11							. . . . .	.	.	24
	Run Alarm and Pre-start Alarm	.	.			Single Input
				12						. . . . .	.	.	24
						Fire Department Input
	Maximum Open Direction Current Setting	.	.	12. .		. . . . . Open Input				. . . . .	.	.	24
	Maximum Close Direction Current Setting	.	. .	12		Open Obstruction		. . . . . . . . .	.	. . . . . . .	. .	.	.24
						Close Obstruction		. . . . . . . . .	.	. . . . . . .	. .	.	.24
						Reverse Input							24
								. . . . . . . . .	.	. . . . . . .	. .	.
						Open Loop				. . . . .	.	.	24
						Reverse Loop		. . . . . . . . .	.	. . . . . . .	. .	.	.24
	WARNING					Shadow/reset Loop		. . . . . . . . .	.	. . . . . . .	. .	.	.24
						Operation Indications		. . . . . . . . .	.	. . . . . . .	. .	.	.24
						Power-up Display				. . . . .	.	.	.24
	ONLY QUALIFIED TECHNICIANS					Idle Condition		. . . . . . . . .	.	. . .. . . . .. . . .	.. .	. .	.24
	SHOULD WORK ON					Last Gate Position/Condition							.24
						Pre-start Delay							.24
	LINEAR SLIDE GATE							. . . . . . . . .	.	. . . . . . .	. .	.
						Reverse Delay				. . . . .	.	.	24
	OPERATORS
						Run Timer. . .							.24
							. . . . . . . . . . . . . . . . . . . . .	. . . . . . . . .	.	. . . . . . .	. .	.
						Error Indications		. . . . . . . . .	.	. . . . . . .	. .	.	.25
						Entrapment. .	. . . . . . . . . . . . . . . . . . . . .	. . . . . . . . .	.	. . . . . . .	. .	.	.25
						COMM LINK Connection Failure				. . . . .	.	.	.25
						MGT Obstacle Transmitter Trouble		. . . . . . . . .	.	. . . . . . .	. .	.	.25
						. .Maximum Run Time Exceeded				. . . . . . . 25
	WARNING					Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
						Contacting Technical Support		. . . . . . . . .	.	. . . . . . .	. .	.	.26
CONTROLS INTENDED FOR USER ACTIVATION MUST		BE				Operator fails to start				. . . . .	.	.	.26
						Motor operates, but gate does not move				. . . . .	.	.	.26
LOCATED AT LEAST SIX FEET (6') AWAY FROM ANY MOVING						Motor sounds like it is working harder than normal. .				. . . . .	. .		26
PART OF THE GATE AND WHERE THE USER IS PREVENTED						Limit switch getting out of time		. . . . . . . . .	.	. . . . . . .	. .	.	.26
FROM REACHING OVER, UNDER, AROUND OR THROUGH THE						Gate stopping part way open or closed (but no visible obstruction).26
						Gate staying open with automatic system				. . . . .	.	. 26
GATE TO OPERATE THE CONTROLS. OUTDOOR OR EASILY
						How to Order Replacement Parts							.26
ACCESSIBLE CONTROLS SHALL HAVE A SECURITY FEATURE								. . . . . . . . .	.	. . . . . . .	. .	.
						Model SLR Exploded View							.27
TO PREVENT UNAUTHORIZED USE.								. . . . . . . . .	.	. . . . . . .	. .	.
						. . . . . . . . . . . . . .Model SLC Exploded View		. . . . . . . . .	.	. . . . . . .	. .	.	.28
						Model SLD Exploded View		. . . . . . . . .	.	. . . . . . .	. .	.	.30
						Model SLD Maintenance. . . . . . . . . . . . . . . . . . . . . . . . .32
						Battery Maintenance				. . . . .	.	.	.32
						DC Motor Brush Replacement		. . . . . . . . .	.	. . . . . . .	. .	.	.32
						Preventative Maintenance		. . . . . . . . .	.	. . . . . . .	. .	.	.33
						General	. . . . . . . . . . . . . . . . . . . . .	. . . . . . . . .	.	. . . . . . .	. .	.	.33
						Lubrication				. . . . .	.	.	33
						6-Month Preventative Maintenance				. . . . .	.	.	33
						FCC Notice				. . . . .	.	.	33
						Gate Operator Installation Checklist				. . . . .	. . 34
SLR • SLC • SLD  Slide Gate Operator Installation Guide					- 2 -			227968 Revision X13 2-3-09