Precor TRM 800 warranty Handrail and console assembly attachment

Page 26

24	Assembling and Maintaining TRM 800-Series Treadmills

7.Route the cable assembly through the cable guides in the fairing, then wrap the guides around the cable assembly to secure it. Push any extra cable into the upright support.

Note: In the following step, use the zinc-finish buttonhead screws and flat washers from the hardware kit.

Important: Do not wrench-tighten the fasteners in the following step until the unit has been fully assembled. Make sure the fasteners do not pinch any cables. The Precor Limited Warranty does not cover cables damaged by improper installation.

8.Secure the fairing assembly using six buttonhead screws and six washers. Partially tighten the fasteners.

Figure 10: Handrail and console assembly attachment

9.Position the ferrite bead on the lower unit data cable inside the left arm of the fairing and secure it in place using a plastic tie.

Image 26

Contents Assembling and Maintaining TRM 800-Series Treadmills Page Page Trademark Note Intellectual Property NoticeImportant Safety Instructions Safety PrecautionsAssembling and Maintaining TRM 800-Series Treadmills Safety Code Educating Users Hazardous Materials and Proper DisposalProduct Recycling and Disposal Regulatory Notices for the Rfid ModuleIndustry Canada Radio Frequency Interference RFIFederal Communications Commission, Part European Applications Safety Approvals for Cardiovascular EquipmentRegulatory Notices for Cardiovascular Exercise Equipment Cardiovascular Type EquipmentUser’s authority to operate the equipment Treadmill Grounding Instructions Electrical Recommendations 240 V TreadmillsObtaining Service Obtaining Updated Documentation North American 120-volt, 20-amp power receptacleTable of Contents Commercial Cardiovascular Equipment Limited Warranty To prepare the treadmill for assembly Assembling the TreadmillInstallation Requirements Required ToolsHardware Kit not to scale FastenersUnpacking the Cables To unpack the cablesRemoval and replacement of the rear fairing cover To begin assembly of the frame Assembling the FrameUpright support attachment, right side To thread cables through the frame PointUpright support attachment, left side Handrail and console assembly attachment To secure the fasteners Completing AssemblyTo complete assembly of the treadmill base Attaching the Power Cord Clips To attach the power cord clipsChecking Treadmill Alignment and Adjusting the Running Belt Power cord placement under front of treadmillLeveling the Unit To level the treadmillPlugging In the Power Cord Breaking in the EquipmentAssembling and Maintaining TRM 800-Series Treadmills Installing the Console Threading the Cable Assembly P80To thread the cable assembly Removing the access cover from the P80 consoleConnecting Cables P80 Connecting the Television Cable To connect the television cableConnecting the Ethernet and Base Unit Data Cables Connecting the television cableConnecting the Heart Rate Sensor Cable Connecting the Power CableCompleting the Console Installation P80 To complete the installationThreading the Cable Assembly P30 and P20 Connecting Cables P30 Connecting Cables P20 Completing the Console Installation P30 and P20 Reassembling the Treadmill Fairing To reassemble the fairingVerifying That the Heart Rate Display Is Operational To verify that the heart rate display is operationalAssembling and Maintaining TRM 800-Series Treadmills Maintenance Daily CleaningDaily Inspection Weekly Maintenance Monthly MaintenanceAdjusting the Running Belt To adjust the running beltChecking the Alignment of the Running Belt To align the running beltTo put the treadmill into an inclined position for moving Storing the Chest StrapMoving the Equipment Long-Term Storage Assembling and Maintaining TRM 800-Series Treadmills Entering the Safety Code To enter the safety code and start the treadmillUsing the Treadmill Safety Clip Restart switchLocation Weight LimitTurning the Treadmill On and Off Assembling and Maintaining TRM 800-Series Treadmills Limited Warranty Warranty Periods and CoverageConditions and Restrictions Exclusive Remedies Exclusion of Consequential and Incidental Damages Complete this portion and keep for your recordsPage Precor Incorporated