American Dryer AD-120ES manual Table of Contents

Page 5

	Table of Contents
SECTION I
IMPORTANT INFORMATION
A.	RECEIVING and HANDLING	2
B. SAFETY PRECAUTIONS		3
SECTION II
SUPER AD-30 SPECIFICATIONS
A.	SPECIFICATIONS (Gas and Steam Models)	5
B.	COMPONENT IDENTIFICATION	7
SECTION III
INSTALLATION PROCEDURES
A. LOCATION REQUIREMENTS		9
B.	UNPACKING/SETTING UP	10
C.	DRYER ENCLOSURE REQUIREMENTS	12
D.	FRESH AIR SUPPLY	13
E.	EXHAUST REQUIREMENTS	14
F.	ELECTRICAL INFORMATION	21
G.	GAS INFORMATION	27
H.	STEAM INFORMATION	31
I.	PREPARATION FOR OPERATION / START-UP	35
J.	PREOPERATIONAL TESTS	36
K.	OPERATING INSTRUCTIONS	39
L.	SHUT DOWN INSTRUCTIONS	40
SECTION IV
SERVICE / PARTS INFORMATION
A.	SERVICE	41
B.	PARTS	41
SECTION V
WARRANTY INFORMATION
A. RETURNING WARRANTY CARD(S)		42
B. WARRANTY		42
C. RETURNING WARRANTY PART(S)		42
SECTION VI
ROUTINE MAINTENANCE
A.	CLEANING	44
B.	ADJUSTMENTS	46
C.	LUBRICATION	46
SECTION VII
TROUBLESHOOTING		47
SECTION VIII
REVERSING TIMER SPIN / DWELL ADJUSTMENTS		58
SECTION X
PROCEDURE FOR FUNCTIONAL CHECK OF REPLACEMENT COMPONENTS		59

Image 5

Contents AD-120ES Retain This Manual In a Safe Place For Future Reference For Your Safety Page Table of Contents Important Information SectionWhat to do if YOU Smell GAS Safety PrecautionsStandards Specifications Specifications / Component IdentificationADG-120ES ADE-120ES ADS-120ES Dryer Front View Component IdentificationDryer Rear View Location Requirements Installation ProceduresUNPACKING/SETTING UP Leveling Dryer Dryer Enclosure Requirements Fresh AIR Supply General Exhaust Duct Work Information Exhaust RequirementsPage Single Dryer Venting Multiple Dryer Common Venting Page ADG-120ES for GAS Models ADE-120ES for 80 KW Electric Models Page Electrical Information ADG-120ES Reversing, 3ø GAS ADS-120ES Reversing, 3ø Steam Electrical Service Specifications PER DryerADE-120ES 72 Kw Electric Reversing, 3ø ADE-120ES 80 Kw Electric Reversing, 3ø Page Page Gas Supply GAS InformationType of Gas Page Page Steam Requirements , High Pressure Installation InstructionsSteam Coil PH Level Steam Damper System Steam Damper System Operation Steam Damper AIR System ConnectionsSteam Damper AIR Piston Flow Control Operation Adjustment Preparation for Operation Natural GAS Preoperational TestsPage Page Operating Instructions Shut Down Instructions Parts SERVICE/PARTS InformationService Returning Warranty Cards Warranty InformationWarranty Returning Warranty PartsPage Cleaning Routine MaintenanceDays Lubrication AdjustmentsDrive motor not operating does not start TroubleshootingNo L.E.D. display microprocessor computer models only Blower motor not operating does not start Microprocessor controller computer display reads door Microprocessor computer display reads dSFLPage No heat for Electric Models only No heat for Steam Models onlyCondensation on main door glass Dryer operates but is taking too long to dryExcessive noise and/or vibration Dryer or scraping noise at basket tumbler areaBlower impellor/fan motor only not operating does not start Failed reversing timer for Reversing Models onlyDrive motor only not operating does not start Dryer operates but is taking too long to dry load Heat unit not operating for only one 1 temperature selectionFailed hi-limit thermostat for GAS and Electric Models only Sail switch is fluttering for GAS and Electric Models onlyDryer scraping noise at basket tumbler area Timing Legend Reversing Timer SPIN/DWELL AdjustmentsMicroprocessor computer Board Procedure for Functional Check Replacement ComponentsDirect Spark Ignition DSI System