Section 1 • Safety
18.International Requirements
This vessel and its systems have been constructed in accordance with standards and specifications in effect at the time of manufacture as published by the various regulatory authorities listed below.
1.Ministere De La Mer – France
2.Registro Italiano Navale – Italy
3.Det Norske Veritas – Norway
4.Securite des Nauires – Canada
5.J.C.I. (Japan Craft Inspection) – Japan
6.N.K.K. (Nippon Kaiji Kyokai) – Japan
7.B.S.I. (British Standards Institute) – England
8.Ministerio Obras Publicas Y Transporters – Spain
9.EC Recreational Craft Directive – European Community
Further information concerning these requirements may be obtained from Baja® Marine Customer Service: 1-865-971-6270.
19.Environmental Considerations
The following warning is offered for boats sold in the State of California in accordance with California Heath & Safety Code §§ 25249.5-.13:
!WARNING
A wide variety of components used on this vessel contain or emit chemicals known to the State of California to cause cancer and birth defects and other reproductive harm.
Examples include:
•Engine and generator exhaust
•Engine and generator fuel, and other liquids such as coolants and oil, especially used motor oil
•Cooking fuels
•Cleaners, paints, and substances used for vessel repair
•Waste materials that result from wear of vessel components
•Lead from battery terminals and from other sources such as ballast or fishing sinkers
To Avoid Harm:
•Keep away from engine, generator, and cooking fuel exhaust fumes.
•Wash areas thoroughly with soap and water after handling the substances above.
A. Fuel and Oil Spillage
Regulations prohibit discharging fuel or oily waste in navigable waters. Discharge is defined as any action which causes a film, sheen or discoloration on the water surface, or causes a sludge or emulsion beneath the water surface. A common violation is bilge discharge. Use rags or sponges to soak up fuel or oily waste, then dispose of it properly ashore. If there is much fuel or oil in the bilge, contact a knowledgeable marine service to remove it. Never pump contaminated bilge overboard. Help protect your waters.
Fill tank(s) less than rated capacity. Allow for fuel expansion.
Outlaw
Baja Marine
For information call 1-865-971-6270 or fax
Welcome
This page intentionally left blank
Introduction
Manufacturer’s Certification
Service, Parts and Repair for Your Boat
Hull Identification Number HIN
About Your Express Limited Warranty
Iii
Ignition Protection Breakers and/or Fuses
Speed changes you. TM
Safety Labels
Safety
Carbon Monoxide
Legally Mandated Minimum Required Equipment
Fire Extinguishing System
Carbon Monoxide Monitor
Lifesaving Equipment
Impaired Operation
Additional Recommended Equipment for Safe Operation
United States
Power Capacity
Load Capacity
Propellers
Maintain Control
Stability
General Considerations
Chart Your Course
Weather
Skiing
Water Sports
Swimming
General
Emergency Situations
Flooding, Swamping and Capsizing
Medical Emergency
Water Rescue
Fire
Propulsion, Control or Steering Failure
Safety Hotlines
Collisions and Leaking
Grounding
Fuel and Oil Spillage
International Requirements
Environmental Considerations
Excessive Noise
Waste Disposal
Wake/Wash
Nautical Terms
Key to Symbols on Controls & Prints
Baja Marine Corp
This Page Intentionally Left Blank
Docking /Lifting /Trailering Passenger Locations
General Boat Arrangement
2 Hull
Propulsion System
Basic Boat Dimensions and Clearances Metric
General Deck Layout FIG
General Deck Layout
Gear Shift and Throttle Control
Power Trim Unit and Gauge
Description of Major Controls
Trim Tabs
Trailer Switch
Tachometer and Hour Meter
Ignition Shutdown Switch
Engine Alarm System
Important Gauges
Navigation and Anchor Lights
Oil Pressure, Water Temperature, Voltmeter and Fuel Gauges
Pre-Launch, Launch and Post- Launch Checklist
Using Your Boat
Fueling the Boat
Trailer Launching and Loading
Personal Flotation Devices
Boarding
Starting the Engine
Passenger Instruction and Location
Stopping the Engine
Shifting to Drive the Boat
Hydraulic Steering
Steering Systems
Power Steering System
Power Steering
This page intentionally left blank
Drain Plug
Bilge & Underwater Gear
Bilge
Fuel & Oil Spillage
Vibration and Causes
Maintenance and Service
Engines and Stern Drive
Bilge Blowers
Impact to Stern Drive
Propeller Removal and Installation
Gear case
Anti-Siphon Valve Inboard/Outboard Engine Only
Fuel System
Fuel System
Static Electricity and the Fuel System
Fueling Precautions
Before and During Fueling Checklist
After Fueling Checklist
This page intentionally left blank
Batteries
Electrical Systems
Electrical Systems
Direct Current DC
Fuse Panel
Electrolytic Corrosion & Zinc Anodes
Breakers and/or Fuses
Marine Electronic Cathodic Anti-corrosion System Mercathode
Ignition Switch
Drive Pump with K-Plane Trim Tabs FIG
Switch Panel Wire Information Triple FIG
Switch Panel Wire Information Twin FIG
Wiring Harness Information FIG
DC Distribution Wiring Information FIG
Hull Wiring Harness Information FIG
Gauge Panel Wiring Information FIG
Breaker Panel Wiring Information FIG
Options & Accessories Locations
Options & Accessories
Canvas
Automatic Fire Extinguisher System Option
Fire Extinguisher Port
Horn
Canvas Care and Maintenance
Swim Platform w/ Ladder Optional
Depth Finder Optional
Requirements for Operators
Stereo System
Head Systems
Portable Head with Pump-Out
Vent Filter
Exhaust Systems
VacuFlush Head Option
Holding Tank Operation
This page intentionally left blank
Interval
Required Inspection, Service Maintenance
Summary Guide for Inspection, Service and Maintenance
Interval
Summary Guide For Inspection, Service and Maintenance
Useful Service Information
Bilge Area
Inspection, Service and Maintenance Protocol
Boat Storage
Winterization Checklist for Boats Stored on Land
Batteryies
Topside and Supplies
Miscellaneous
Fitting Out After Storage
Fuel Systems
Fuel System
Security Considerations
Power Steering System Maintenance
Boat Systems
Quick Reference Checklist
Boarding the Boat General
Starting the Engine
Returning to Port General
Quick Reference Checklist cont’d Departing General
If the Engine Does Not Start
Quick Reference Checklist cont’d
Securing the Boat
After Market Equipment Checklist
Maintenance Log
Maintenance Log Cont’d
Fiberglass & Gelcoat
Paint Cleaning Agents & Other Substances
Care & Refinishing
Stains & Scratches
Canvas and Clear Vinyl
Permanently Moored or Docked Boats
Topside Areas
Acrylic Plastic Sheeting Plastic Glass
Interior Upholstery Fabric
Exterior Upholstery Fabric
This Page Intentionally Left Blank
Index
Index Outlaw