40 Outlaw Owner’s Manual • Table of Contents
Introduction | |
1. | This Manual | iii |
2. | Your Responsibilities | iii |
3. | Sources of Information | iii |
4. | Dealer Responsibilities | iii |
5. | Warranties | iii |
6. | Hull Identification Number (HIN) | iv |
7. | Manufacturer’s Certification | iv |
8. | Service, Parts and Repair for Your Boat | iv |
About Your Express Limited Warranty | v |
Section 1 • Safety | |
1. | Safety Labels | 1.1 |
2. | Legally Mandated Minimum Required | |
| Equipment | 1.2 |
3. | Fire Extinguishing System | 1.2 |
4. | Carbon Monoxide | 1.2 |
5. | Lifesaving Equipment | 1.4 |
6. | Additional Recommended Equipment for Safe | |
| Operation | 1.5 |
7. | Impaired Operation | 1.5 |
8. | Load Capacity | 1.6 |
| A. United States | 1.6 |
| B. International | 1.6 |
9. | Power Capacity | 1.6 |
10. | Propellers | 1.6 |
11. | Stability | 1.7 |
12. | Maintain Control | 1.7 |
13. | Weather | 1.8 |
14. | Chart Your Course | 1.8 |
15. | Water Sports | 1.9 |
| A. Swimming | 1.9 |
| B. Skiing | 1.9 |
| C. Diving | 1.10 |
16. | Emergency Situations | 1.10 |
| A. Medical Emergency | 1.11 |
| B. Water Rescue | 1.11 |
| C. Fire | 1.11 |
| D. Flooding, Swamping and Capsizing | 1.11 |
| E. Collisions and Leaking | 1.12 |
| F. Grounding | 1.12 |
| G. Propulsion, Control or Steering Failure | 1.12 |
17. | Safety Hotlines | 1.12 |
18. | International Requirements | 1.13 |
19. | Environmental Considerations | 1.13 |
| A. Fuel and Oil Spillage | 1.13 |
| B. Waste Disposal | 1.14 |
| C. Excessive Noise | 1.14 |
| D. Wake/Wash | 1.14 |
20. | Nautical Terms | 1.15 |
21. Key to Symbols on Controls & Prints | 1.16 |
22. | Warning Label Locations | 1.17 |
Section 2 • General Boat Arrangement | |
1. | | Docking/Lifting/Trailering | 2.1 |
2. | | Passenger Locations | 2.1 |
3. | | Basic Boat Dimensions and Clearances (United |
| | States Standard S.A.E.) | 2.2 |
4. | | Propulsion System | 2.3 |
5. | | Propellers | 2.3 |
6. | | General Deck Layout | 2.4 |
7. | | Description of Major Controls | 2.5 |
| | A. Gear Shift and Throttle Control | 2.5 |
| | B. Power Trim Unit and Gauge | 2.5 |
| | C. Trailer Switch | 2.6 |
| | D. Trim Tabs | 2.6 |
| | E. Ignition Shutdown Switch | 2.7 |
| | F. Engine Alarm System | 2.7 |
8. | | Important Gauges | 2.7 |
| | A. Tachometer and Hour Meter | 2.7 |
| | B. Oil Pressure, Water Temperature, Voltmeter |
| | and Fuel Gauges | 2.8 |
9. | | Navigation and Anchor Lights | 2.8 |
Section 3 • Using Your Boat | |
1. | | Pre-Launch, Launch and Post-Launch Checklist 3.1 |
2. | Trailer Launching and Loading | 3.2 |
3. | | Fueling the Boat | 3.2 |
4. | | Boarding | 3.3 |
5. | | Personal Flotation Devices (PFD’s) | 3.3 |
6. | | Passenger Instruction and Location | 3.4 |
7. | | Starting the Engine | 3.4 |
8. | | Shifting to Drive the Boat | 3.5 |
9. | | Stopping the Engine | 3.5 |
10. | Steering Systems | 3.6 |
| | A. Hydraulic Steering | 3.6 |
| | B. Power Steering | 3.7 |
Section 4 • Bilge & Underwater Gear | |
1. | | Bilge | 4.1 |
| | A. Fuel & Oil Spillage | 4.1 |
| | B. Drain Plug | 4.1 |
| | C. Bilge Pumps | 4.1 |
| | D. Bilge Blower(s) | 4.2 |
Baja Marine
Outlaw
For information call 1-865-971-6270 or fax
Welcome
This page intentionally left blank
Introduction
Manufacturer’s Certification
Service, Parts and Repair for Your Boat
Hull Identification Number HIN
About Your Express Limited Warranty
Iii
Ignition Protection Breakers and/or Fuses
Speed changes you. TM
Safety
Safety Labels
Carbon Monoxide
Legally Mandated Minimum Required Equipment
Fire Extinguishing System
Carbon Monoxide Monitor
Lifesaving Equipment
Additional Recommended Equipment for Safe Operation
Impaired Operation
Power Capacity
Load Capacity
Propellers
United States
Stability
Maintain Control
General Considerations
Chart Your Course
Weather
Skiing
Water Sports
Swimming
Emergency Situations
General
Medical Emergency
Water Rescue
Fire
Flooding, Swamping and Capsizing
Safety Hotlines
Collisions and Leaking
Grounding
Propulsion, Control or Steering Failure
Fuel and Oil Spillage
International Requirements
Environmental Considerations
Excessive Noise
Waste Disposal
Wake/Wash
Nautical Terms
Key to Symbols on Controls & Prints
Baja Marine Corp
This Page Intentionally Left Blank
General Boat Arrangement
Docking /Lifting /Trailering Passenger Locations
2 Hull
Basic Boat Dimensions and Clearances Metric
Propulsion System
General Deck Layout
General Deck Layout FIG
Gear Shift and Throttle Control
Power Trim Unit and Gauge
Description of Major Controls
Trailer Switch
Trim Tabs
Ignition Shutdown Switch
Engine Alarm System
Important Gauges
Tachometer and Hour Meter
Oil Pressure, Water Temperature, Voltmeter and Fuel Gauges
Navigation and Anchor Lights
Using Your Boat
Pre-Launch, Launch and Post- Launch Checklist
Trailer Launching and Loading
Fueling the Boat
Boarding
Personal Flotation Devices
Passenger Instruction and Location
Starting the Engine
Shifting to Drive the Boat
Stopping the Engine
Steering Systems
Hydraulic Steering
Power Steering
Power Steering System
This page intentionally left blank
Bilge & Underwater Gear
Bilge
Fuel & Oil Spillage
Drain Plug
Maintenance and Service
Engines and Stern Drive
Bilge Blowers
Vibration and Causes
Propeller Removal and Installation
Impact to Stern Drive
Gear case
Anti-Siphon Valve Inboard/Outboard Engine Only
Fuel System
Fuel System
Static Electricity and the Fuel System
Fueling Precautions
Before and During Fueling Checklist
After Fueling Checklist
This page intentionally left blank
Electrical Systems
Electrical Systems
Direct Current DC
Batteries
Fuse Panel
Electrolytic Corrosion & Zinc Anodes
Breakers and/or Fuses
Marine Electronic Cathodic Anti-corrosion System Mercathode
Ignition Switch
Drive Pump with K-Plane Trim Tabs FIG
Switch Panel Wire Information Triple FIG
Switch Panel Wire Information Twin FIG
Wiring Harness Information FIG
DC Distribution Wiring Information FIG
Hull Wiring Harness Information FIG
Gauge Panel Wiring Information FIG
Breaker Panel Wiring Information FIG
Options & Accessories
Options & Accessories Locations
Canvas
Automatic Fire Extinguisher System Option
Fire Extinguisher Port
Canvas Care and Maintenance
Swim Platform w/ Ladder Optional
Depth Finder Optional
Horn
Stereo System
Head Systems
Portable Head with Pump-Out
Requirements for Operators
Exhaust Systems
VacuFlush Head Option
Holding Tank Operation
Vent Filter
This page intentionally left blank
Interval
Required Inspection, Service Maintenance
Summary Guide for Inspection, Service and Maintenance
Summary Guide For Inspection, Service and Maintenance
Interval
Useful Service Information
Inspection, Service and Maintenance Protocol
Bilge Area
Winterization Checklist for Boats Stored on Land
Batteryies
Topside and Supplies
Boat Storage
Fitting Out After Storage
Fuel Systems
Fuel System
Miscellaneous
Power Steering System Maintenance
Security Considerations
Boat Systems
Quick Reference Checklist
Boarding the Boat General
Starting the Engine
Quick Reference Checklist cont’d Departing General
Returning to Port General
If the Engine Does Not Start
Quick Reference Checklist cont’d
Securing the Boat
After Market Equipment Checklist
Maintenance Log
Maintenance Log Cont’d
Paint Cleaning Agents & Other Substances
Care & Refinishing
Stains & Scratches
Fiberglass & Gelcoat
Permanently Moored or Docked Boats
Topside Areas
Acrylic Plastic Sheeting Plastic Glass
Canvas and Clear Vinyl
Exterior Upholstery Fabric
Interior Upholstery Fabric
This Page Intentionally Left Blank
Index
Index Outlaw