Thermos The Big Easy Quickset Traditional LP Gas Grill Flames blow out, Flare-up, Fire can damage

Page 29

Problem	Possible Cause	Prevention/Cure


Flames blow out.	High or gusting winds.	Turn front of grill to face wind or
		increase flame height.
	Low on LP gas.	Refill LP tank.
	Excess flow valve tripped.	Refer to "Sudden drop in gas flow"
		above.

Flare-up.	Grease buildup.	Clean grill.
	Excessive fat in meat.	Trim fat from meat before grilling.
	Excessive cooking	Adjust (lower) temperature
	temperature.	accordingly.

Persistent grease	Grease trapped by food	Turn knob(s) to OFF. Turn gas off
fire (can damage	buildup around burner	at LP tank. Leave lid in position and
the appearance of	system.	let fire burn out. After grill cools,
steel panels and		remove, clean all parts and replace
aluminum castings		soup can.
on the grill).	Grease soaked into briquets	Replace briquets. If cooking with
	Grease soaked into briquets	Replace briquets. If cooking with
		fatty meats remove briquets.

Flashback...	Burner and/or burner tubes	Turn knob(s) to OFF. Clean burner
(fire in burner	are blocked.	and/or burner tubes.
tube(s)

Unable to fill LP	Some dealers have older fill	The worn nozzles don't have
tank.	nozzles with worn threads.	enough "bite" to engage the valve.
		Try a second LP dealer.

One burner	Grease or food particles in	Clean carry-over tube(s) with wire
doesn't	slot underneath lip on carry-	brush.
light off other	over tube
burner(s)

29

Image 29

Contents Use Gas Grill Use And CareFor Your Safety Safety Symbols Installation Safety PrecautionsTable of Contents Valve Retainer Cap Strap LP Tank Removal, Transport And StorageLP Tank LP Liquefied Petroleum Gas LP TankLP Tank Filling Equipped with this type of valveFor your safety Connecting Regulator To The LP TankLP Tank Exchange LP Tank Leak TestInto the LP tank valve LP tank valve so as not to cross thread the connectionNipple has to be centered At end of valve Leak Testing Valves, Hoses and RegulatorTurn all grill control knobs to OFF Apartment Dwellers For Safe Use Of Your Grill And To Avoid Serious InjuryUse grill at least 3 ft. from any wall or surface Ignitor Lighting Traditional and Quick Set Before Your First CookoutDo not lean over grill while lighting Match lighting hole is in bottom or sideRotisserie Burner Ignitor Lighting Ignitor Lighting Big EasyOpen lid during lighting. Turn gas on at LP tank Left Side of GrillBurner Flame Check Sideburner Ignitor LightingTurning Grill Off Ignitor CheckCare Of Wood General Grill CleaningRepainting Your Grill If YOU Experience the Following 1. Smell gas Typical spider webs inside burnerTurn gas off at control knobs and LP tank Cleaning The Traditional Burner AssemblyIgnitor Cleaning The Quick Set Burner Assembly Remove button and battery on electronic ignition models Cleaning The Big Easy Burner Assembly Valve Burner Tube Clip Ceramic InsulatorLates Indirect CookingYou will need Grill SmokingVery Important Burner tube must engage gas tube as shown D Cleaning The Rotisserie BurnerWeight Time Tips Cooking Chart For Rotisserie BurnerTemperatures High = 650 F0 / Medium = 450 F0 / Low = 300 F0 Cooking ChartFood Setting Cooking Time How To Tell If Meat Is Grilled Thoroughly Food SafetyProblem Possible Cause Prevention/Cure Troubleshooting GeneralFlare-up Flames blow outPersistent grease Fire can damageStoring Your Grill Troubleshooting Electronic Ignition SystemProblem Possible Cause Check Procedure Solution Present but not Sparks areAt all electrodes And/or not at Full strengthConsumer Warranty / P.O. Box Columbus, GA WarrantysElectronic Ignition System 10 Year Limited Warranty