Thermos The Big Easy Quickset Traditional LP Gas Grill manual LP Tank Exchange, LP Tank Leak Test

Page 7

Safety Relief Valve

LP Tank Exchange

•Many retailers that sell grills offer you the option of replacing your empty LP tank through an exchange service. Use only those reputable exchange companies that inspect, precision fill, test and certify their cylinders. Exchange your tank only for an OPD safety feature-equipped tank as described in the "LP Tank" section of this manual.

•Always keep new and exchanged LP tanks in upright position during use, transit or storage.

•Leak test new and exchanged LP tanks BEFORE connecting to grill.

LP Tank Leak Test

For your safety

•Leak test must be repeated each time LP tank is exchanged or refilled.

•Do not smoke during leak test.

•Do not use an open flame to check for gas leaks.

•Grill must be leak checked outdoors in well-ventilated area, away from ignition sources such as gas fired or electrical appliances. During leak test, keep grill away from open flames or sparks.

Use a clean paint brush and 50/50 soap and water solution. Use mild

soap and water. ▲ Do not use household cleaning agents. Damage

to gas train components can result.

Brush soapy solution onto the shaded areas.

If "growing" bubbles appear do not use or move the LP tank. Contact an LP gas supplier or your fire department!

Connecting Regulator To The LP Tank

1.LP tank must be properly secured onto grill. (Refer to Assembly Manual)

2.Turn all control knobs including sideburner (if featured) to the OFF position.

3.Turn LP tank OFF by turning hand- wheel clockwise to a full stop.

4.Remove the protective cap from LP tank valve. Always use cap and strap supplied with valve.

O	Clockwise
ff

Strap and Cap

OPD Hand

Wheel

Type 1 outlet with thread on outside

7

Image 7

Contents Use Gas Grill Use And CareFor Your Safety Safety Symbols Installation Safety PrecautionsTable of Contents LP Tank LP Tank Removal, Transport And StorageValve Retainer Cap Strap Equipped with this type of valve LP TankLP Liquefied Petroleum Gas LP Tank FillingLP Tank Leak Test Connecting Regulator To The LP TankFor your safety LP Tank ExchangeNipple has to be centered LP tank valve so as not to cross thread the connectionInto the LP tank valve Turn all grill control knobs to OFF Leak Testing Valves, Hoses and RegulatorAt end of valve Use grill at least 3 ft. from any wall or surface For Safe Use Of Your Grill And To Avoid Serious InjuryApartment Dwellers Match lighting hole is in bottom or side Before Your First CookoutIgnitor Lighting Traditional and Quick Set Do not lean over grill while lightingLeft Side of Grill Ignitor Lighting Big EasyRotisserie Burner Ignitor Lighting Open lid during lighting. Turn gas on at LP tankIgnitor Check Sideburner Ignitor LightingBurner Flame Check Turning Grill OffRepainting Your Grill General Grill CleaningCare Of Wood If YOU Experience the Following 1. Smell gas Typical spider webs inside burnerTurn gas off at control knobs and LP tank Cleaning The Traditional Burner AssemblyIgnitor Cleaning The Quick Set Burner Assembly Remove button and battery on electronic ignition models Cleaning The Big Easy Burner Assembly Valve Burner Tube Clip Ceramic InsulatorLates Indirect CookingYou will need Grill SmokingVery Important Burner tube must engage gas tube as shown D Cleaning The Rotisserie BurnerWeight Time Tips Cooking Chart For Rotisserie BurnerFood Setting Cooking Time Cooking ChartTemperatures High = 650 F0 / Medium = 450 F0 / Low = 300 F0 How To Tell If Meat Is Grilled Thoroughly Food SafetyProblem Possible Cause Prevention/Cure Troubleshooting GeneralFire can damage Flames blow outFlare-up Persistent greaseProblem Possible Cause Check Procedure Solution Troubleshooting Electronic Ignition SystemStoring Your Grill And/or not at Full strength Sparks arePresent but not At all electrodesElectronic Ignition System 10 Year Limited Warranty WarrantysConsumer Warranty / P.O. Box Columbus, GA