Thermos The Big Easy Quickset Traditional LP Gas Grill Troubleshooting Electronic Ignition System

Page 30

Troubleshooting - Electronic Ignition System

Problem		Possible Cause	Check Procedure	Solution


No sparks		Battery not installed	Check battery	Install battery (make sure
appear at any		properly.	orientation.	that "+" and "–" connectors
electrodes				are oriented correctly, with
when	ignition			"+" end down and "–" end
button	is			up.)
pushed; no
noise can be		Dead battery.	Has battery been	Replace battery with new
heard from			used previously?	AAA-size alkaline battery.
spark module.		Button assembly not	Check to insure	Unscrew button cap
		Button assembly not	Check to insure	Unscrew button cap
		installed properly.	threads are properly	assembly and reinstall,
			engaged. Button	making sure threads are
			should travel up and	aligned and engaged fully.
			down without
			binding.
		Faulty spark	If no sparks are	Replace spark module
		module.	generated with new	assembly.
			battery and good
			wire connections,
			module is faulty.
No sparks		Output lead	Are output	Remove and reconnect all
appear at any		connections not	connections on and	output connections at
electrodes		complete.	tight?	module and electrodes.
when	ignition

switch is pushed; noise can be heard from spark module.

Storing Your Grill

•Clean cooking grate(s) and discard old briquets.

•Store in dry location.

•When LP tank is connected to grill, store outdoors in well-ventilated space and out of reach of children.

•Cover grill if stored outdoors. Choose from a variety of grill covers offered by Char-Broil.

•Store grill indoors ONLY if LP tank is turned off and disconnected, removed from grill and storedoutdoors.

•When removing grill from storage follow "Cleaning Burner Assembly" instructions before startinggrill.

30

Image 30

Contents Gas Grill Use And Care UseFor Your Safety Installation Safety Precautions Safety SymbolsTable of Contents LP Tank Removal, Transport And Storage LP TankValve Retainer Cap Strap LP Tank Filling LP TankLP Liquefied Petroleum Gas Equipped with this type of valveLP Tank Exchange Connecting Regulator To The LP TankFor your safety LP Tank Leak TestLP tank valve so as not to cross thread the connection Nipple has to be centeredInto the LP tank valve Leak Testing Valves, Hoses and Regulator Turn all grill control knobs to OFFAt end of valve For Safe Use Of Your Grill And To Avoid Serious Injury Use grill at least 3 ft. from any wall or surfaceApartment Dwellers Do not lean over grill while lighting Before Your First CookoutIgnitor Lighting Traditional and Quick Set Match lighting hole is in bottom or sideOpen lid during lighting. Turn gas on at LP tank Ignitor Lighting Big EasyRotisserie Burner Ignitor Lighting Left Side of GrillTurning Grill Off Sideburner Ignitor LightingBurner Flame Check Ignitor CheckGeneral Grill Cleaning Repainting Your GrillCare Of Wood Typical spider webs inside burner If YOU Experience the Following 1. Smell gasCleaning The Traditional Burner Assembly Turn gas off at control knobs and LP tankIgnitor Cleaning The Quick Set Burner Assembly Remove button and battery on electronic ignition models Cleaning The Big Easy Burner Assembly Ceramic Insulator Valve Burner Tube ClipIndirect Cooking LatesGrill Smoking You will needCleaning The Rotisserie Burner Very Important Burner tube must engage gas tube as shown DCooking Chart For Rotisserie Burner Weight Time TipsCooking Chart Food Setting Cooking TimeTemperatures High = 650 F0 / Medium = 450 F0 / Low = 300 F0 Food Safety How To Tell If Meat Is Grilled ThoroughlyTroubleshooting General Problem Possible Cause Prevention/CurePersistent grease Flames blow outFlare-up Fire can damageTroubleshooting Electronic Ignition System Problem Possible Cause Check Procedure SolutionStoring Your Grill At all electrodes Sparks arePresent but not And/or not at Full strengthWarrantys Electronic Ignition System 10 Year Limited WarrantyConsumer Warranty / P.O. Box Columbus, GA