Thermos The Big Easy Quickset Traditional LP Gas Grill LP Tank Removal, Transport And Storage

Page 5

•The safety relief valve on the LP tank could activate releasing gas and cause an intense fire with risk of death or serious injury.

•NEVER store a spare LP tank under or near grill or in enclosed areas.

•Never fill the cylinder beyond 80% full. An overfilled spare LP tank is hazardous due to possible gas released from the safety relief valve.

•If you see, smell or hear escaping gas, immediately get away from the LP tank/grill and call your fire department.

•All spare LP tanks must have safety caps installed on the LP tank outlet.

LP Tank Removal, Transport And Storage

•Turn OFF all control knobs and LP tank valve. Turn coupling nut counterclockwise by hand only - do not use tools to disconnect. Lift LP tank wire upward off of LP tank collar, then lift LP tank up and off of support bracket. Install safety cap onto LP tank valve. Always use cap and strap supplied with valve. Failure to use safety cap as directed may result in serious personal injury and/or property damage.

LP Tank		Safety
Valve	Retainer	Cap
	Strap

•A disconnected LP tank in storage or being transported must have a safety cap installed (as shown). Do not store an LP tank in enclosed spaces such as a carport, garage, porch, covered patio or other building. Never leave a LP tank inside a vehicle which may become overheated by the sun.

•Do not store LP tank in an area where children play.

5

Image 5

Contents Use Gas Grill Use And CareFor Your Safety Safety Symbols Installation Safety PrecautionsTable of Contents Valve Retainer Cap Strap LP Tank Removal, Transport And StorageLP Tank LP Liquefied Petroleum Gas LP TankLP Tank Filling Equipped with this type of valveFor your safety Connecting Regulator To The LP TankLP Tank Exchange LP Tank Leak TestInto the LP tank valve LP tank valve so as not to cross thread the connectionNipple has to be centered At end of valve Leak Testing Valves, Hoses and RegulatorTurn all grill control knobs to OFF Apartment Dwellers For Safe Use Of Your Grill And To Avoid Serious InjuryUse grill at least 3 ft. from any wall or surface Ignitor Lighting Traditional and Quick Set Before Your First CookoutDo not lean over grill while lighting Match lighting hole is in bottom or sideRotisserie Burner Ignitor Lighting Ignitor Lighting Big EasyOpen lid during lighting. Turn gas on at LP tank Left Side of GrillBurner Flame Check Sideburner Ignitor LightingTurning Grill Off Ignitor CheckCare Of Wood General Grill CleaningRepainting Your Grill If YOU Experience the Following 1. Smell gas Typical spider webs inside burnerTurn gas off at control knobs and LP tank Cleaning The Traditional Burner AssemblyIgnitor Cleaning The Quick Set Burner Assembly Remove button and battery on electronic ignition models Cleaning The Big Easy Burner Assembly Valve Burner Tube Clip Ceramic InsulatorLates Indirect CookingYou will need Grill SmokingVery Important Burner tube must engage gas tube as shown D Cleaning The Rotisserie BurnerWeight Time Tips Cooking Chart For Rotisserie BurnerTemperatures High = 650 F0 / Medium = 450 F0 / Low = 300 F0 Cooking ChartFood Setting Cooking Time How To Tell If Meat Is Grilled Thoroughly Food SafetyProblem Possible Cause Prevention/Cure Troubleshooting GeneralFlare-up Flames blow outPersistent grease Fire can damageStoring Your Grill Troubleshooting Electronic Ignition SystemProblem Possible Cause Check Procedure Solution Present but not Sparks areAt all electrodes And/or not at Full strengthConsumer Warranty / P.O. Box Columbus, GA WarrantysElectronic Ignition System 10 Year Limited Warranty