Desa VTGF33NRB, VTGF33PRB installation manual Parts List, KEY Part Number Description QTY

Page 33

PARTS LIST

REMOTE CONTROL LOG BASE ASSEMBLY MODELS

VTGF33PRB AND VTGF33NRB

This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 31 of this manual.

KEY

PART

 

 

KEY

PART

 

 

NO.

NUMBER

DESCRIPTION

QTY.

NO.

NUMBER

DESCRIPTION

QTY.

1

110103-01

Ember Bed Log

1

42

104015-01

Power Cord

1

2

110105-02

Left Front Log

1

43

110885-01

Inlet Tube

1

3

110105-01

Right Front Log

1

44

107568-01

Main Power Cable

1

4

110105-03

Rear Log

1

45

110063-02

Burner, Front

1

5

110105-04

Right Crossover Log

1

46

111458-01

Burner Alignment

 

6

110104-01

Left Crossover Log

1

 

 

Bracket

1

7

103904-02

Electrode

1

47

099415-12

Pressure Regulator

 

8

104285-02

ODS Pilot (Natural)

1

 

 

(Natural)

1

 

104286-02

ODS Pilot (Propane/LP)

1

 

099415-18

Pressure Regulator

 

9

110093-05

Electrode Bracket

1

 

 

(Propane/LP)

1

10

099387-09

Pilot Tube

1

48

097809-03

Fitting 3/8" Flare to

 

11

111323-01

Pilot Shield

1

 

 

1/2" NPT

1

12

108105-01

Rear Burner

1

49

101628-03

Flexible Connector

1

13

102843-01

Burner Clip

1

50

110884-01

Burner Tube

1

14

107110-01

Spacer

2

51

099056-27

Injector (Rear Burner)

 

15

100321-01

Spacer

2

 

 

Natural Gas

1

16

107566-01

Module, Control Board

1

 

099056-29

Injector (Rear Burner)

 

17

102349-01

Support, PCB

4

 

 

Propane/LP Gas

1

18

107565-01

Receiver Assembly

1

52

101004-15

Injector (Front Burner)

 

19

107565-02

Sensor Assembly

1

 

 

Natural Gas

1

20

098303-02

Screw, #6

2

 

101004-18

Injector (Front Burner)

 

21

M11084-50

Screws

4

 

 

Propane/LP Gas

1

22

108631-01

Log Alignment Screw

9

53

101004-11

Injector (Middle Burner)

 

23

**

Firebox Bottom

1

 

 

Natural Gas

1

24

107563-01

Wall Switch and Cord

1

 

101004-18

Injector (Middle Burner)

 

25

107558-01

Wall Switch

 

 

 

Propane/LP Gas

1

 

 

Decorative Plate

1

54

110063-01

Middle Burner

1

26

107561-01

Wall Plate Decal

1

55

108134-01

NG Rear Plate

1

27

100694-01

Screw, #6 x 11/4" PH

2

56

108188-02

U-Drive Screw

1

28

107847-01

Screw, #619 x 1/4"

2

57

099998-01

Fan Switch

1

29

109157-01

Sensor Bracket

1

58

101480-11

High Temp Black

 

30

102445-01

Piezo Ignitor

1

 

 

Wire Assembly

1

31

107564-01

Remote Control

1

59

099125-13

Terminal Board

1

32

107562-01

Switch and Wire Assy

1

60

099157-01

3-16 Break Mandrell

 

33

110111-01

Bracket, Switch

 

 

 

Rivet

1

 

 

and Piezo

1

 

PARTS AVAILABLE — NOT SHOWN

 

34

102334-01

Palnut Fastener

1

 

 

 

19724000

Cable Tie

4

35

107573-01

Valve Bracket

1

 

 

901056-01

Flare Adapter Fitting,

 

36

107743-01

Thermocouple Tube

1

 

 

 

 

3/8" NPT

1

37

107559-01

Gas Control Valve

 

 

 

 

 

107736-01

Wall Plate Assy Kit

1

 

 

(Natural)

1

 

 

 

 

 

(Contains Items

 

 

107559-02

Gas Control Valve

 

 

 

 

 

 

 

 

31, 33, 44)

 

 

 

(Propane/LP)

1

 

 

 

 

 

 

107737-01

Wall Switch Assy Kit

1

38

107560-01

Magnetic Manual

 

 

 

 

 

(Contains Items

 

 

 

Override Handle

1

 

 

 

 

 

 

 

28, 30, 31, 33, 44)

 

39

110108-01

Burner Shield

1

 

 

 

 

107766-01

Battery, 12V, 23A

 

40

098544-01

Wire Support Clip

1

 

 

 

 

Remote

1

41

101629-01

1.5" Bushing

2

 

 

 

 

 

 

 

 

 

 

 

 

 

 

** Not a field replacement part.

113134-01B

www.desatech.com

33

Page 32 Page 34
Image 33
Page 32 Page 34
Contents What to do if YOU Smell GAS Table of Contents Safety Information Product Identification Local Codes Product FeaturesUnpacking AIR for Combustion VentilationDetermining FRESH-AIR Flow for Heater Location Providing Adequate VentilationUnusually Tight Construction Confined Space and Unconfined SpaceVentilation AIR Ventilation Air From Inside BuildingVentilation Air From Outdoors Installation Clearances InstallationCheck GAS Type Electrical HookupInstallation Sequence Removing Fireplace Screen and Floor AssemblyMinimum 16 inches from Side Wall Relocating Wall Switch Assembly Electrical Connections for Power CordFor Mantel Installation For Recessed InstallationMounting Wall Switch Assembly to Wall for Recessed Fireplace Remove wall switch assembly from bracketMounting Wall Switch Assembly to Side of Mantel Opening in Wall or Mantel Wall Wall Switch Assembly ScrewsInstallation Items Needed Installing GAS Piping to Fireplace LocationAssembly, Connecting Fireplace to GAS SupplyNatural Check all gas connections for leaks. SeeChecking GAS Connections Test Pressures Equal To or Less Than 1/2 Psig 3.5 kPaTest Pressures In Excess Of 1/2 Psig 3.5 kPa Break off nailing flanges see with hammer or pliers Conventional Fireplace InstallationInserting Fireplace Into Cabinet Mantel BUILT-IN Fireplace InstallationAttaching Fireplace to Wall Studs Assembling Perimeter Trim Installing HoodInstalling Log #2 Right Log #3 Left Installing LogsInstalling Screen Installing Battery Into RemoteFor Your Safety Read Before Lighting Operating FireplaceUsing Supplied Wall Switch Assembly Using Hand-Held Wireless Remote ControlNormal Lighting Instructions Shutting Off Heater Wall Switch Manual Lighting Instructions for Electrical Power OutageShutting Off Heater Wireless Remote Control To Turn OFF GAS To ApplianceOptional Blower Operation Inspecting BurnersOperating FAN Pilot Flame PatternYou could damage the pilot assembly Inspected yearly by a qualified service personBurner Flame Patterns Burner Injector HoldersCleaning Maintenance SpecificationsLogs Observed Problem Possible Cause Remedy TroubleshootingGas regulator defective Nance, Replace regulator Not enough air Check burner for dirt OperationOn windows Tilation air Turning control knob toProblem could be caused by Clean ODS/pilot seeAssembly EnoughStatement above Gas leak. See WarningService Hints Replacement PartsTechnical Service Parts Under WarrantyIllustrated Parts Breakdown KEY Part Number Description QTY Parts ListFireplace Models VTGF33NRB and VTGF33PRB 100639-01 104356-02 Not a field replacement part Accessories Cabinet Mantel and Full Hearth Base Laminate Trim for Hearth or MantelFire Crackle CF6-A Extruded Louver KIT Receiver and HAND-HELD Thermostat Remote Control KIT Ghrctb Receiver and HAND-HELD Remote Control KIT GhrcbFirebox Brick Liner G8005 Diameter Holes Diameter 2 Holes TemplatesThis page Intentionally Left Blank Wiring Diagram 113134-01B 113134-01B Warranty Information Keep this WarrantyLimited Warranty VENT-FREE GAS Fireplace

VTGF33NRB, VTGF33PRB specifications

Desa VTGF33PRB and VTGF33NRB are advanced heating solutions that combine innovative technology and design for optimal performance and user convenience. These models are well-suited for residential and commercial applications, providing efficient heating while enhancing the overall aesthetic of any space.

One of the main features of the VTGF33PRB and VTGF33NRB is their high-efficiency ratings, which allow them to deliver effective heating with minimal energy consumption. This efficiency not only helps users save on energy bills, but it also makes these models environmentally friendly, aligning with modern sustainability goals.

Both models utilize advanced infrared heating technology, which generates heat by directly warming objects and people in the room rather than heating the air. This results in a more comfortable and even distribution of warmth, providing immediate relief from cold temperatures. The infrared heating method is particularly beneficial in large or drafty spaces, as it can significantly reduce heating times and energy usage.

In terms of design, the VTGF33PRB features a sleek, modern appearance that can easily complement any décor. Its robust construction ensures durability, making it suitable for long-term usage. The VTGF33NRB, on the other hand, offers a more traditional aesthetic, perfect for those who prefer classic designs. Both models are user-friendly, designed with intuitive controls that allow for easy operation and temperature adjustments.

Another noteworthy characteristic of the Desa VTGF33 series is their safety features. Each unit is equipped with advanced safety mechanisms, including tip-over protection, overheat shut-off, and a sturdy base to prevent accidents. These safety features provide peace of mind for users, especially in households with children or pets.

The VTGF33PRB and VTGF33NRB also incorporate quiet operation technology, ensuring that heating is achieved without disruptive noise. This makes them ideal for use in bedrooms, offices, or any space where tranquility is desired.

Overall, the Desa VTGF33PRB and VTGF33NRB are exemplary models that showcase the harmonious blend of efficiency, safety, and design. Their advanced features and technologies make them reliable choices for anyone looking to enhance their heating solutions while maintaining comfort and style. With their commitment to quality and innovation, Desa continues to lead the way in the heating industry.
Top Page Image Contents