Coleman 9924 Series Operation, Burner and Orifice, Leak Check, To Light, English-5

■Remove plastic cap from top of propane bottle and screw propane bottle into regulator hand tight. (Fig. 8)

Fig. 8

Operation

DANGER

•CARBON MONOXIDE HAZARD

•For outdoor use only.

•Never use inside house, camper, tent, vehicle or other unventilated or enclosed areas. This grill consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life.

■Never operate grill with propane cylinder in an inverted position. (Fig. 9)

Fig. 9

DANGER

• EXPLOSION - FIRE HAZARD

• Propane is heavier than air and can accumu-

late in low places. If you smell gas, leave the

Burner and Orifice

■Proper location of the burner with respect to the orifice is important. To verify the proper installa- tion of the burner tube, turn the grill upside down and look through the grill vents on the right side. The burner tube must be located over the brass orifice fitting.

See Fig. 10 (grill case not shown).

Burner Tube

Brass Orifice Fitting

Fig. 10

■Check and clean the burner/venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the appliance.

Leak Check

WARNING

•Perform leak test outdoors.

•Extinguish all open flames.

•NEVER leak test when smoking.

•Do not use the outdoor grill until connection has been leak tested and does not leak.

■Note: Use Coleman 16.4 oz. disposable propane cylinders. The LP-gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP-gas cylinders of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods.

area immediately.

• Always attach or detach propane source out-

doors; never while grill is lighted, near flame,

pilot lights, other ignition sources or while grill

is hot to touch.

• This grill is very hot during use and can ignite

flammables too close to the burners. Minimum

distance from sides and back of unit to walls

or railings is 12 inches (30.5 cm). Do not use

under overhead unprotected combustible con-

struction. Keep gasoline and other flammable

liquids and vapors well away from grill.

■ Do not attempt to operate until you have read

and understood all General Safety Information in

this manual and all assembly is complete and

leak checks have been performed.

To Light

WARNING

•BURN HAZARD

•This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from hot surfaces or splatter from cooking liquids.

•Never leave grill unattended when hot or in use.

•Keep out of reach of children.

Match Light Grills

■Set on sturdy, flat surface. For outdoor use only.

■Remove grill surface.

■Hold lighted match near burner and open regulator valve. (Fig. 11)

English-5