Brinkmann Heavy-Duty Natural Gas Grill owner manual Cooking Grills, Heat Distribution Plates

Page 15

BURNER ASSEMBLY/MAINTENANCE CONTINUED

Note: Follow the "Gas Leak Testing" section of this manual. Relight burners to verify proper operation.

12. Replace heat distribution plates and cooking grills.

PROPER BURNER OPERATION

COOKING GRILLS

•Clean with mild soap detergent and water. A brass bristled brush or a nylon cleaning pad can be used to remove residue from the stainless steel surfaces. Do not use steel wire bristles to clean the cooking grills. Steel can cause the finish to chip or crack. DO NOT use a commercial oven cleaner.

HEAT DISTRIBUTION PLATES

•Periodically, it may be necessary to inspect and clean the heat distribution plate to prevent excess grease build-up. When the grill is cold, remove the cooking grills. Inspect the heat distribution plates and replace if broken or damaged. Do not allow heat distribution plates to become damaged to the extent that they may fall through onto the burners. Replace the heat distribution plates and cooking grills and light the burners. Operate the grill on "HIGH" for 10 minutes to remove the excess grease.

WARNING

TRANSPORTING AND STORAGE:

•Never move a grill when it is hot or when objects are on the cooking surfaces.

•Make sure that natural gas supply is shut off. After moving the grill check that all gas connections are free of leaks. Refer to instructions for Leak Testing.

•DO NOT store a spare LP gas cylinder (filled or empty) under or near the grill.

•Never store flammable liquids or spray canisters under or near the grill.

•DO NOT extinguish grease fires using water.

•If the outdoor cooking gas appliance is not in use, the gas must be turned off at the gas supply.

•When removing the grill from storage, spider webs or other debris may be blocking the burner. See "Burner Assembly/Maintenance" under Proper Care and Maintenance.

14

Image 15

Contents Avis À ’INSTALLATEUR If YOU Smell GAS Important SafetyTable of Contents Save this Manual for Future Reference General WarningsInstallation Information Disconnecting Your Grill from the Natural GAS Source Connecting Your Grill to the Natural GAS SourceLeak Testing When to Perform a Leak TestChecking for Leaks PRE-START Check List Lighting Instructions Lighting the Main BurnersMatch Lighting the Main Burners Lighting the Side Burner Match Lighting the Side BurnerTurning OFF the Grill Controlling FLARE-UPS Operating the GrillBreaking in Your Grill Preheating the GrillSide Burner Rotisserie CookingCleanliness Grilling to Proper TemperatureHelpful Hints Burner ASSEMBLY/MAINTENANCE Cleaning and MaintenanceCooking Grills Heat Distribution PlatesTransporting and Storage Before Storing Your Grill Trouble ShootingFrequently Asked Questions Frequently Asked Questions Parts BAG Contents Parts List Assembly InstructionsPage Step Step Panels to avoid injury to Step Attach hose heat shield using two #8 self-tapping screws Place side burner grate over side burner Step Grease Tray Grease Cup Southgate 8445-N Assembled Importantes Relatives À LA Sécurité Mises EN GardeTable DES Matières Mises EN Garde Mises EN Garde GénéralesRenseignements SUR L’INSTALLATION Déconnecter LE Grill DE L’ALIMENTATION EN GAZ Naturel Connecter UN Grill À UNE Source DE GAZ NaturelÉpreuves D’ÉTANCHÉITÉ Quand Effectuer UN Essai D’ÉTANCHÉITÉVérification DES Fuites Liste DE Contrôle Avant L’ALLUMAGE Consignes D’ALLUMAGE Allumage DES Brûleurs PrincipauxAllumage DES Brûleurs Principaux À L’AIDE D’UNE Allumette Allumage DU Brûleur Latéral Allumage DU Brûleur Latéral À L’AIDE D’UNE AllumetteFermeture DU Gril Contrôle DES Embrasements Utilisation DU GrilMise EN Marche DE Votre Gril Préchauffage DU GrilBrûleur Latéral Cuisson AU TournebrochePropreté Grillage À LA Bonne TempératureConseils Utiles Assemblage ET Entretien DES Brûleurs Nettoyage ET EntretienTransport ET Entreposage Assemblage DU Brûleur / Entretien SuiteGrilles DE Cuisson Plaques DE Diffusion ThermiqueDépannage Avant Dentreposer Votre GrilQuestions Posées Fréquemment Questions Posées Fréquemment Contenu DU SAC DE Pièces Liste DES Pièces Instructions D’ASSEMBLAGEPage Étape Tige à Ressort Pivot de Porte Trou de Alignement Étape Fixez le brûleur latéral sur le côté Avertissement Grille de Réchauffage Plateau à Graisse Boîte à Graisse Southgate 8445-N Assemblé Warranty