| TROUBLESHOOTING (ENGINE) | ||
|
|
| |
| TABLE 7. TROUBLESHOOTING (ENGINE) | ||
|
|
| |
SYMPTOM | POSSIBLE CAUSE | SOLUTION | |
|
|
| |
| Spark plug bridging? | Check gap, insulation or replace spark plug. | |
|
|
| |
Difficult to start, "fuel is available, but | Carbon deposit on spark plug? | Clean or replace spark plug. | |
|
| ||
|
| ||
no SPARK at spark plug". | Short circuit due to deficient spark plug | Check spark plug insulation, replace if worn. | |
| insulation? | ||
|
| ||
|
|
| |
| Improper spark plug gap? | Set to proper gap. | |
|
|
| |
| ON/OFF switch is shorted? | Check switch wiring, replace switch. | |
|
|
| |
| Ignition coil defective? | Replace ignition coil. | |
Difficult to start, "fuel is available, and |
|
| |
Improper spark gap, points dirty? | Set correct spark gap and clean points. | ||
SPARK is present at the spark plug". |
|
| |
| Condenser insulation worn or short circuiting? | Replace condenser. | |
|
|
| |
| Spark plug wire broken or short circuiting? | Replace defective spark plug wiring. | |
|
|
| |
| Wrong fuel type? | Flush fuel system, and replace with correct type of fuel. | |
|
|
| |
Difficult to start, "fuel is available, | Water or dust in fuel system? | Flush fuel system. | |
spark is present and compression is |
|
| |
|
| ||
normal". | Air cleaner dirty? | Clean or replace air cleaner. | |
|
|
| |
| Choke Open? | Close Choke. | |
|
|
| |
| Suction/exhaust valve stuck or protruded? | ||
|
|
| |
Difficult to start, "fuel is available, | Piston ring and/or cylinder worn? | Replace piston rings and or piston. | |
|
| ||
|
| ||
spark is present and compression is | Cylinder head and/or spark plug not tightened | Torque cylinder head bolts and spark plug. | |
low". | properly? | ||
| |||
|
|
| |
| Head gasket and/or spark plug gasket | Replace head and spark plug gaskets. | |
| damaged? | ||
|
| ||
|
|
| |
| Fuel not available in fuel tank? | Fill with correct type of fuel. | |
|
|
| |
| Fuel filter clogged? | Replace fuel filter. | |
No fuel present at the carburetor. |
|
| |
Fuel tank cap breather hole clogged? | Clean or replace fuel tank cap. | ||
| |||
|
|
| |
| Air in fuel line? | Bleed fuel line. | |
|
|
|