HTC PDA PHONE II, Andes service manual 72H00401-00

Page 20

The LCM, Speaker , MIC is located on upper part (Bezel side).

Before disassembly LCM, It is required to unscrew two screws of the speaker, and remove it from its place.

P/N: 72H00401-00

Speaker

To Disassembly LCM module

Hold the entire assembly as seen on the picture , push aside the bezel and push the panel from front side simultaneously . Notice the starting location.

Doing this to release the LCM from 4 hooks which located 2 at its right and left respectively.

Then, gently pull out the LCM from its lower part hook .

HTC confidential

© 2001, HTC Corporation. All rights reserved.

TOTAL 77 CONT.ON. 21 PAGE NO. 20

Image 20

Contents For PDA Phone Andes APP´D Table of contents 4END Introduction ContainsSpecification of AC Adapter GSM/GPRS Functional BlockGPRS/GSM 400MHzTotal 77 CONT.ON page no Total 77 CONT.ON page no TTE System Block Diagram Main unit Regulatory label on the rear housing of main unit LabelingTBD Label example01 ~ Servicing Tools Assembling and Disassembling PDA PhoneTotal 77 CONT.ON page no Total 77 CONT.ON page no Total 77 CONT.ON page no Use tweezers to remove the Vibrator 72H00401-00 Total 77 CONT.ON page no MB Pre-assembly Gasket on shielding cover72H00411-00 Black poron of Send/End buttonBlack poron for volume button PN of this poron is 76H00483-00Total 77 CONT.ON page no Total 77 CONT.ON page no N72H00338-00 Antenna Assembly72H00339-00 77H00083-00 Warranty Seal Security LabelFIX Antenna Cover Test Camera Replacement assemby Connector, Back up battery replacement PadProblem Diagnostics List of Test JigsDiagnostic Program Clean Talk TimeHow to select test item Stop on failChecksum Refurbishment Total 77 CONT.ON page no To Main battery To PC Com Port Voltage 2.5 Criteria for Eeprom Block 1 Status B2. Procedure B1. RequirementCriteria on running Run Down Test Program Capacity ≧ 50 %Current consumption measurement Fixture requirementReady for testing Unit is turn off and no display Single dots Bright dotsSingle Dark dotsOr lints Power Off status All allowable defect dotsForeign Scratch Scratch, Object11.RF 11.1RF Test RequirementGSM 900 Transmitter Test RF Antenna Test SpecRF Antenna Spec DCS 1800 Receiver Test OS Upgrade and GSM code Upgrade Execute RUU Next Total 77 CONT.ON page no Done Following is the complete procedure for SD reflash Execute MTTY.exe and set into USB PortSerial V1.02 Following display will be shown on PC display … Then press ENTER, following display will be shown 100% Checksum is OK HTC confidential SD Download Sections=3 Press Power To Flash…… Once it is Done, display will show Classification of Non-Conformity Troubleshooting & Repair －Ａ．Touch Panel Does Not Respond to Screen Tap－B．Buttons Do Not Respond －A．SD Card cannot be used －A．Data Retention related problem －B．Battery discharges quickly even after fully charged －A．No Recorded Sound or Distorted sound Exploded Diagrams & Spare part list Spare part list Spare Part List with Picture 72H00339-00 75H00313-00 Appendix Customer, Retailer MisjudgmentHTC confidential FTP Repair Troubleshooting Guide Flow Total 77 CONT.ON. F page no