HTC PDA PHONE II, Andes service manual Antenna Assembly, 72H00339-00, N72H00338-00

Page 26

Next Close the Rear Housing to upper part starting from left side (with Volume button)

TIPS:

Adjust the volume button to its center first before full closing the Housing .

Antenna Assembly

Put the antenna into its place, starting from upper part, then press and insert its two ribs correctly to the housing.

Then fasten two screws of the antenna. Continuing with 2 screws at the lower bottom of housing.

P/N: 72H00339-00

Torque : 1.2 kg-cm

Next four screws at the middle part of housing ,

P/N:72H00338-00

Torque : 0.8 kg-cm

HTC confidential

© 2001, HTC Corporation. All rights reserved.

TOTAL 77 CONT.ON. 27 PAGE NO. 26

Image 26

Contents For PDA Phone Andes APP´D Table of contents 4END Introduction ContainsSpecification of AC Adapter GSM/GPRS Functional BlockGPRS/GSM 400MHzTotal 77 CONT.ON page no Total 77 CONT.ON page no TTE System Block Diagram Main unit Regulatory label on the rear housing of main unit LabelingTBD Label example01 ~ Servicing Tools Assembling and Disassembling PDA PhoneTotal 77 CONT.ON page no Total 77 CONT.ON page no Total 77 CONT.ON page no Use tweezers to remove the Vibrator 72H00401-00 Total 77 CONT.ON page no 72H00411-00 MB Pre-assemblyGasket on shielding cover Black poron of Send/End buttonBlack poron for volume button PN of this poron is 76H00483-00Total 77 CONT.ON page no Total 77 CONT.ON page no N72H00338-00 Antenna Assembly72H00339-00 77H00083-00 Warranty Seal Security LabelFIX Antenna Cover Test Camera Replacement assemby Connector, Back up battery replacement PadProblem Diagnostics List of Test JigsDiagnostic Program Clean Talk TimeHow to select test item Stop on failChecksum Refurbishment Total 77 CONT.ON page no To Main battery To PC Com Port Voltage 2.5 Criteria for Eeprom Block 1 Status Criteria on running Run Down Test Program B2. ProcedureB1. Requirement Capacity ≧ 50 %Current consumption measurement Fixture requirementReady for testing Unit is turn off and no display Single Single dotsBright dots Dark dotsForeign Scratch Or lints Power Off statusAll allowable defect dots Scratch, Object11.RF 11.1RF Test RequirementGSM 900 Transmitter Test RF Antenna Test SpecRF Antenna Spec DCS 1800 Receiver Test OS Upgrade and GSM code Upgrade Execute RUU Next Total 77 CONT.ON page no Done Following is the complete procedure for SD reflash Execute MTTY.exe and set into USB PortSerial V1.02 Following display will be shown on PC display … Then press ENTER, following display will be shown 100% Checksum is OK HTC confidential SD Download Sections=3 Press Power To Flash…… Once it is Done, display will show Classification of Non-Conformity Troubleshooting & Repair －Ａ．Touch Panel Does Not Respond to Screen Tap－B．Buttons Do Not Respond －A．SD Card cannot be used －A．Data Retention related problem －B．Battery discharges quickly even after fully charged －A．No Recorded Sound or Distorted sound Exploded Diagrams & Spare part list Spare part list Spare Part List with Picture 72H00339-00 75H00313-00 Appendix Customer, Retailer MisjudgmentHTC confidential FTP Repair Troubleshooting Guide Flow Total 77 CONT.ON. F page no