HTC PDA PHONE II, Andes service manual Total 77 CONT.ON page no

Page 8

Interface

Stylus

Keyboard/Button/Switch

Notification

One Infrared port IrDA SIR

One 22 pin individual Port for signals (for USB, Serial, Car Kit, Power and Audio)

One SIM card slot

One SDIO/MMC card slot (B-Square SDIO driver) One 34 pin Back pack connector

One Audio Jack (2.5 ψ)

Lock type mechanism

One five way navigation button One Power button(wake-up key)

One volume control button(up & down) Two phone button, SEND(Yes) & END(No) (Wake-up keys),with LED backlight

Two programmable AP buttons(Wake up key) Camera (Side button)

Press to launch camera capture utility, and take picture for 2nd press

Voice command/Voice recorder (side button) Press for voice command

Press and hold for Voice recorder Reset Switch

Key lock function support by software

One Bi-color LED for GSM standby, GSM message, GSM network status, PDA notification, PDA Charging status.

One Blue LED for Bluetooth system notification of powered –ON and ready to transmit RF signal. Notification by sound, Message, Vibration on the display.

HTC confidential

© 2001, HTC Corporation. All rights reserved.

TOTAL 77 CONT.ON. 9 PAGE NO. 8

Image 8

Contents For PDA Phone Andes APP´D Table of contents 4END Introduction ContainsSpecification of AC Adapter GSM/GPRS Functional BlockGPRS/GSM 400MHzTotal 77 CONT.ON page no Total 77 CONT.ON page no TTE System Block Diagram Main unit Regulatory label on the rear housing of main unit LabelingTBD Label example01 ~ Servicing Tools Assembling and Disassembling PDA PhoneTotal 77 CONT.ON page no Total 77 CONT.ON page no Total 77 CONT.ON page no Use tweezers to remove the Vibrator 72H00401-00 Total 77 CONT.ON page no MB Pre-assembly Gasket on shielding cover72H00411-00 Black poron of Send/End buttonBlack poron for volume button PN of this poron is 76H00483-00Total 77 CONT.ON page no Total 77 CONT.ON page no N72H00338-00 Antenna Assembly72H00339-00 77H00083-00 Warranty Seal Security LabelFIX Antenna Cover Test Camera Replacement assemby Connector, Back up battery replacement PadProblem Diagnostics List of Test JigsDiagnostic Program Clean Talk TimeHow to select test item Stop on failChecksum Refurbishment Total 77 CONT.ON page no To Main battery To PC Com Port Voltage 2.5 Criteria for Eeprom Block 1 Status B2. Procedure B1. RequirementCriteria on running Run Down Test Program Capacity ≧ 50 %Current consumption measurement Fixture requirementReady for testing Unit is turn off and no display Single dots Bright dotsSingle Dark dotsOr lints Power Off status All allowable defect dotsForeign Scratch Scratch, Object11.RF 11.1RF Test RequirementGSM 900 Transmitter Test RF Antenna Test SpecRF Antenna Spec DCS 1800 Receiver Test OS Upgrade and GSM code Upgrade Execute RUU Next Total 77 CONT.ON page no Done Following is the complete procedure for SD reflash Execute MTTY.exe and set into USB PortSerial V1.02 Following display will be shown on PC display … Then press ENTER, following display will be shown 100% Checksum is OK HTC confidential SD Download Sections=3 Press Power To Flash…… Once it is Done, display will show Classification of Non-Conformity Troubleshooting & Repair －Ａ．Touch Panel Does Not Respond to Screen Tap－B．Buttons Do Not Respond －A．SD Card cannot be used －A．Data Retention related problem －B．Battery discharges quickly even after fully charged －A．No Recorded Sound or Distorted sound Exploded Diagrams & Spare part list Spare part list Spare Part List with Picture 72H00339-00 75H00313-00 Appendix Customer, Retailer MisjudgmentHTC confidential FTP Repair Troubleshooting Guide Flow Total 77 CONT.ON. F page no