Graco 313289s important safety instructions With Wall Power, Manual

Page 53

313289S
J-Box Model
WHT 1120				Power
BLK 1123				Power
BLK 1123				Filter
			(115306)
			PE
IEC-320 cord
				BRN
				BLUE
				GRN/YEL
Models with cord only
				WHT
				WHT
				BLK
				GRN
	Nema 5-65
		manual	NOTE: NC

J1

1

2+V_CAN

3V_CAN_RTN

4

5

Power

Supply

(15V747)

	P3		P4
CAN_L	P3		1	CAN_L
	1		1	CAN_L
	1		2	+V_CAN
+V_CAN	2		2	+V_CAN
+V_CAN	2		3	V_CAN_RTN
V_CAN_RTN	3		3	V_CAN_RTN
V_CAN_RTN	3		4	CAN_H
CAN_H	4	USB Base	4	CAN_H		USB Component
CAN_H	4	USB Base	5	SHLD		USB Component
SHLD	5	Module				Module
		Module	P1		J2	Module
		(289899)	P1		J2	(289900)
			1	V CAN		1
			2	V CAN		2
			3	V CAN		3
			4	V CAN RTN		4
			5	V CAN RTN		5
			6	CHASSIS GND		6
			7	CHASSIS GND		7
			8	V CAN RTN		8
			9	V CAN RTN		9
			10	BIT3		10
			11	BIT2		11
			12	GND		12
			13	SCK		13
			14	S0		14
			15	S1		15
			16	V CAN		16
			17	V CAN		17
			18	V CAN		18
			19	V CAN RTN		19
			20	V CAN RTN		20
			21	CAN L		21
			22	CAN H		22
			23	V CAN RTN		23
			24	V CAN RTN		24
			25	BIT0		25
			26	BIT1		26
			27	VTOKEN		27
			28	LOFO		28
			29	/HOLD		29
			30	/CS		30

Detailed Electrical Schematic, XM Sprayer

53	indicates the wire is not connected. See 312359 for power connection instructions.

		J6	J7
		J6	1
	CAN_L	1	1
	CAN_L	1	2
	+V_CAN	2	2
	+V_CAN	2	3
	V_CAN_RTN	3	3
	V_CAN_RTN	3	4
	CAN_H	4	4
	CAN_H	4	5
	SHLD	5	5
	SHLD	5
			J1
			1
			2
			3
			4
			5
			6
			7
			8
		Display	9
		Display	10
		Module, Rear	11
		(288997)	12
		(288997)	13
		Front	14
		(255727)

J4

1

2

3

4

5

6

7

8

9

J2

1

2

3

4

CAN_L

+V_CAN

V_CAN_RTN

CAN_H

SHLD

	BUTTON_DOWNARW
	BUTTON_UPARW
	BUTTON_CLEAR
	BUTTON_STOP
	BUTTON_FUNC4
	BUTTON_FUNC1
	BUTTON_START
	BUTTON_RIGHTARW
	BUTTON_LEFTARW
	BUTTON_ENTER
	BUTTON_FUNC3	Membrane
	BUTTON_FUNC2	Membrane
	COM(BUTTONS)	(15R336)
	SHLD
	LED_YELLOW
	LED_BLUEA
	LED_GREEN
	NOT USED
	LED_BLUEB
	NOT USED
	LED_RED
	NOT USED
	COM(LEDS)
		Harness,
	SIG	Key
	SIG	Switch
	COM	Switch
	NC	(15M974)
	NC	(15M974)
	NC

with Wall Power (page 1)

Electrical Schematics

Image 53

Contents XM Plural-Component Sprayers313289S Contents Manual Description Related ManualsComponent Manuals in U.S. English Fire and Explosion Hazard Intrinsic Safety Equipment Misuse Hazard Location Category Key ModelsXM a XM B XM D XM C XM E ApprovalsIsocyanate Hazard OverviewMaterial Self-Ignition Moisture Sensitivity IsocyanatesKeep Components a and B Separate Components a and BChanging Materials Lift Using a Hoist Lift Using a ForkliftBefore Repair Location Proper Lifting of SprayerRelieve Pump Fluid Pressure Pressure Relief ProcedureRelieve a and B Fluid Pressure Flush Before Using Equipment Flush Mixed Material FlushFlush Mix Manifold Use Solvent PumpFollow Pressure Relief Procedure, Empty and Flush Entire System new sprayer or end of job ProcedureGuidelines Turn on heaters until fluid lines are clear of sol- ventR3123593132896 R3123593132897 Relieve pressure. See Pressure Relief Procedure, Cleaning ProcedureShutdown Entire System Flush Entire System new sprayer or end of job onXM Setup and Troubleshooting Guide Problem Cause Solution TroubleshootingSee Appendix a in manual Tor Power Supply Control Compo View Alarms AlarmsDiagnose Alarms Clear AlarmsAlarm Code Alarm Problem When Active Cause Solution Alarm Codes and TroubleshootingSee Pump Assembly, Pump Test Daily Check Recommended Optional User-Settable Maintenance Warnings Optional User-Settable Spray Limits Mode Control Logic Alarms Possible Alarms by ModeR2D StopAlarm Code Key LED Diagnostic InformationModule Status LED Signal Diagnosis Solution What Alert WhereReplace Air Filter Element RepairMain Air Inlet Manifold Filter Both FiltersRemove Shroud User Interface/Control BoxReplace Solenoid Module DVA DVBReplace USB Module Update USB Module SoftwareLoad software. See Update USB Module Soft Ware Replace Fluid Control Module FCM Update Fluid Control Module FCM SoftwareLoad software. See Update Fluid Control Module FCM Software Display Replace AlarmUpgrade Software Replace Display Replace Display BatteryReplace Front Panel Wall Power Supply Control ComponentsReplace Power Supply Module Alternator Module Repair Alternator Power Supply Control ComponentsFCM USBReplace Alternator Regulator Air Controls Gauge 326 319 330 340 331 Mix Manifold Assembly Fluid Control AssemblyDosing Valve Assembly Replace Fluid Pressure Sensor Temperature RTD SensorSensors Remove Displacement Pump Pump AssemblyRemove Pump Assembly Remove Air Motor Solvent Pump Service and RepairFluid Heaters ReplaceSimplified Electrical Schematic, XM Sprayer with Alternator Electrical SchematicsElectrical Schematics 313289S Simplified Pneumatic Schematic, XM Sprayer with Alternator313289S Detailed Electrical Schematic, XM Sprayer with AlternatorBlue Green Detailed Electrical Schematic, XM Sprayer with AlternatorXM Plural Component Sprayer with Wall Power Simplified Electrical Schematic, XM Sprayer with Wall PowerSimplified Pneumatic Schematic, XM Sprayer with Wall Power Manual With Wall PowerDetailed Electrical Schematic, XM Sprayer with Wall Power Box Wiring SchematicsFluid HeatersHopper Heaters Junction Box Wiring Schematics 313289S XM Plural-Component Sprayers PartsXM1, XM2 XM3, XM4XM7, XM8 Models XMB and XMEXM5, XM6 113 114 120 121 122 135 137 115 Common Parts Fluid Control Assembly PartsPart Description Qty See Air Controls Module Parts,XM1 and XM2 Models Parts Varying by ModelXM1 and XM2 Models XM Plural-Component Sprayer Models Part Description XM3 and XM4 ModelsXM3 and XM4 Models XM5 and XM6 Models Adapter XM7 and XM8 Models XM7 and XM8 Models Control Box 255771 Parts Air Power and Electric Power VersionsPart Description LabelMODULE, USB BaseAlternator Assembly Control Box Power Supply OptionsWall Power Supply Assembly Cable Connections Wall Power Supply AssemblyAdapter Air Controls Module 255761 PartsRegulator CouplingJunction Box 256540 Parts Switch 25ACircuit Breaker 25A Circuit Breaker 10ASENSOR, RTD Fluid Control Assembly PartsCAP Plug Air Inlet Manifold 255762 PartsSwivel Turbine Alternator Module 255728 PartsRepair and Spare Parts Reference Part Description Qty Part of AssemblyAccessories and Kits Desiccant Dryer Kit Electric Heated Hose Power Supply KitShutoff/Check Valve Kit Caster KitSystem Dimensions without Hoppers DimensionsTwo 20-Gallon Hoppers Rear Mounted System Dimensions with HoppersTwo 20-Gallon Hoppers Side Mounted Two 7-Gallon Hoppers One 20-Gallon Hopper and One 7-Gallon HopperPTFE, Uhmwpe Technical DataGraco Information Graco Standard Warranty