•When using an extension cord, be sure to use one heavy enough to carry the current your product will draw. An undersized cord will cause a drop in line voltage resulting in loss of power and overheating. The following table shows the correct size to use depending on cord length and nameplate ampere rating. If in doubt, use the next heavier gage. The smaller the gage number, the heavier the cord.
Recommended Minimum Wire Size for Extension Cords
Total Length of Cord | 75 ft. | 100 ft. | 125 ft. | 150 ft. | 175 ft. | |
25 ft. | 50 ft. | |||||
7.6m 15.2 m 22.9 m 30.5 m 38.1 m 45.7 m 53.3 m
Wire Size AWG
18 18 16 16 14 14 12
| FUNCTIONAL DESCRIPTION | A |
|
| ||
| Figure A |
|
|
|
| |
1. | Trigger switch |
|
|
|
| |
2. | Forward/Reverse button | 4 |
|
|
| |
3. | Chuck collar | 3 |
|
|
| |
4. | 1/4 inch hex | 5 |
| 2 |
| |
5. | LED Work light |
|
| |||
1 |
|
| ||||
6. | Bit tip holder |
|
|
|
| |
7. | Battery |
|
|
|
| |
8. | Battery Release Button | 8 |
|
|
| |
(on battery) |
|
|
|
| ||
|
|
|
|
| 6 |
|
|
|
| 7 |
|
|
|
| This product uses the battery and charger listed in the chart below. |
|
| |||
| Description |
| Catalog # |
|
| |
|
|
|
|
|
|
|
| 18V |
| BTC480L |
|
| |
| 18V |
| BTC490L, BTC492L |
|
| |
|
|
|
|
|
|
|
Important Safety Instructions for Battery Chargers SAVE THESE INSTRUCTIONS: This manual contains important safety instructions for battery chargers.
WARNING: Before using charger, read all instructions and cautionary markings on charger, battery pack, and product using battery pack.
•Shock hazard. Do not allow any liquid to get inside charger.
•Burn hazard. To reduce the risk of injury, charge only designated BOSTITCH batteries. Other types of batteries may burst causing personal injury and damage.
•Under certain conditions, with the charger plugged in to the power supply, the charger can be shorted by foreign material. Foreign materials of a conductive nature such as, but not limited to, steel wool, aluminum foil, or any buildup of metallic particles should be kept away from charger cavities. Always unplug the charger from the power supply when there is no battery pack in the cavity. Unplug charger before attempting to clean.
•DO NOT attempt to charge the battery pack with any chargers other than the ones in this manual. The charger and battery pack are specifically designed to work together.
•These chargers are not intended for any uses other than charging designated BOSTITCH rechargeable batteries. Any other uses may result in risk of fire, electric shock or electrocution.
•Do not expose charger to rain or snow.
5