Quadra-Fire MTVERNON-AE-PMH, MTVERNON-AE-MBK, MTVERNON-AE-CWL Piece LOG SET Installation

Page 20

R

Mt. Vernon Pellet Stove (AE)

E. Optional Log Set Placement Instructions

2 PIECE LOG SET INSTALLATION

1.Place the left log as shown. There are 2 indentations in the bottom of the log to fit over the screw heads in the firebox. Figures 20.1 and 20.2.

2.Place the right log in front of the 2 screw heads in the firebox. Figures 20.3 & 20.4.

CAUTION

Logs are FRAGILE. Use extreme care when handling or cleaning logs.

Right Log

Log rests in front of screws

Left Log

Log fits over screws

Figure 20.1

Log has indentations on the bottom to fit over the screw heads.

Figure 20.3

Figure 20.4

NOTICE:

Due to the abrasive nature of a pellet appliance fire, the logs are not covered under warranty. Any placement vari- ation other than shown here can cause excessive heat and shall void the appliance warranty.

Figure 20.2

Page 20

7034-106E

September 1, 2008

Image 20
Contents Installation Operation Hot glass will cause burnsMt. Vernon Pellet Stove AE Mfg Date Test Lab & Report NoTable of Contents Listing and Code Approvals Getting Started Appliance LocationDraft Wall Control ThermostatNegative Pressure Inspect Appliance & Components and Pre-Use Check List Mt. Vernon Pellet Stove AE Fire SafetyTools And Supplies Needed 76-152mm Adapter To 6 in 76-152mm Offset Adapter 3Dimensions and ClearancesAppliance Dimensions Exception for Horizontal Installations Hearth Pad Requirements UL and ULC4Vent Information Venting Termination Minimum RequirementsDo not Terminate Vent Termination must exhaust above air inlet elevationMt. Vernon Pellet Stove AE Chimney and Exhaust Connection Equivalent Feet of PipeExample of 3 Elbow-Rear Vent Termination Calculation See FigureMt. Vernon Pellet Stove AE Pipe Selection Chart Altitude in Thousands of Feet5Venting Systems AlcoveMt. Vernon Pellet Stove AE Through The Wall Straight OutDegree Vertical Interior Typical Installation Through The Wall & Vertical ExteriorMt. Vernon Pellet Stove AE Masonry Alternate Masonry6Mobile Home Installation Outside Air Kit Instructions 7Appliance Set-UpLeg Leveling System Mt. Vernon Pellet Stove AE Top Vent Adapter Installation Adapter InstallationInstalling the Top Vent Adapter Rear Vent and Rear Vent to Top VentPiece LOG SET Installation Back Side of Wall Control with Cover Off Operating Instructions Fuel Size, Material and StorageStarting Your First Fire See Wall Control Thermostat ManualFor detailed operating instructions Battery Back-up System Optional Ignition CyclesStart-Up Auto / Man L, ML, M, MH, HAuto-Clean Auto / Man L, ML, M, MH, H Cont’dShutdown Additional Screen MessagesMt. Vernon Pellet Stove AE Quick Start Guide Wall Control for ReferenceSetting Comfort Level Mt. Vernon Pellet Stove AE Quick Start Guide Cont’dMt. Vernon Pellet Stove AE Frequently Asked Questions Issues SolutionsError Message Possible Cause Corrective ActionQuick Reference Maintenance Chart Cleaning or Inspection10Maintaining & Servicing Your Appliance WeeksCleaning Ash Pan Frequency Types of FuelAlternate Fuel Daily See Disposal of Ashes belowCleaning Heat Exchanger & Drop Tube Mt. Vernon Pellet Stove AE Cleaning the Hopper Cleaning the GlassCleaning Convection Blower Requires No Lubrication Cleaning the Top Vent Adapter if installedHigh Ash Fuel Content Maintenance Preparing Firebox for Non-Burn SeasonConvection Blower Replacement Combustion Exhaust Blower Replacement Reference Materials Component FunctionsPower Supply Thermocouple Drop Tube Vacuum SwitchOverheat Sensor Snap Disc Thermocouple FirepotMt. Vernon Pellet Stove AE Component Locations Left SideMt. Vernon Pellet Stove AE Exploded Drawings Description Part NumberMt. Vernon Pellet Stove AE Mt. Vernon Pellet Stove AE Service Parts and Accessories Item No AccessoriesMt. Vernon Pellet Stove AE TOUCHUP-CSB Item No Mt. Vernon Pellet Stove AE Service And Maintenance Log Date of Service Performed By Description of ServiceDate of Service Performed By Description of Service Mt. Vernon Pellet Stove AE Homeowner’s Notes Mt. Vernon Pellet Stove AE Warranty Policy CONDITIONS, Exclusions & Limitation of LiabilityHearth & Home Technologies Limited Warranty Cont’d T O T O