Quadra-Fire MTVERNON-AE-PMH, MTVERNON-AE-MBK, MTVERNON-AE-CWL Mt. Vernon Pellet Stove AE

Page 44

R

Mt. Vernon Pellet Stove (AE)

Item No.

Service Parts

Part No.

42	Bracket, Latch Assembly	7034-014
	Bracket, Overheat Sensor (Snap Disc)	7034-150
	Bracket, Vacuum Switch	7034-211
18	Clip, Half, for Auto Clean System	7000-321
14	Clip, Hitch Pin 3/32, Qty: 10	7000-374/10
71	Clip, Receiver, Black	704-832
	Clip, Wire, Qty: 10	7000-400/10
	Component Pack, Mahogany (includes owner’s manual, warranty card, quick start	7034-037
	guide, heat exchanger 7 exhaust cleaning instructions, DVD “How To”, wall control &
	harness, power cord, (4) leveling nuts & bolts, ﬁrepot clean-out tool, touch-up paint
	and label “If Fireplace Altered”)
	Component Pack, Matte Black, (see above for contents)	7034-034
	Component Pack, Sienna Bronze, (see above for contents)	7034-035
	Component Pack, Willow, includes, (see above for contents)	7034-036
48	Control Board	SRV7000-456
51	Detent Pin for Convection Blower	7000-376
37	Door Assembly	7034-006
6	Door Frame Assembly	7034-026
7	Door, Air Deﬂector	7034-185
2	Door Latch Assembly	7034-039
70	Door, Left, Matte Black	7005-110MBK
70	Door, Left, Porcelain Mahogany	7005-110PMH
70	Door, Left, Powder Coat, Sienna Bronze	7005-110CSB
70	Door, Left, Powder Coat, Willow	7005-110CWL
36	Door, Right, Matte Black	7005-109MBK
36	Door, Right, Porcelain, Mahogany	7005-109PMH
36	Door, Right, Powder Coat, Sienna Bronze	7005-109CSB
36	Door, Right, Powder Coat, Willow	7005-109CWL
	Elbow, Catch	7000-393
49	Exhaust Transition Assembly	7034-139
	Face Plate, located behind Ash Removal Door	7034-124
54	Feed Motor, DC Current	SRV7000-313
	Feed Motor & Spring Assembly	7034-004
59	Feed Spring Only	SRV7001-046
20	Firepot Assembly	SRV7034-010
15	Firepot Bottom	7034-153
	Firepot Clean-Out Tool	414-1140
	Firepot Riser Clamp Assembly	7034-012
	Firepot Riser Assembly	SRV7034-002
69	Front, Matte Black	7005-108MBK
69	Front, Porcelain, Mahogany	7005-108PMH
69	Front, Powder Coat, Sienna Bronze	7005-108CSB
69	Front, Powder Coat, Willow	7005-108CWL
39	Gasket, (Rope), Ash Door	SRV7034-178
40	Gasket, (Rope), Door	SRV7034-177

Page 44

7034-106E

September 1, 2008

Image 44

Contents Installation Operation Hot glass will cause burnsMt. Vernon Pellet Stove AE Mfg Date Test Lab & Report NoTable of Contents Listing and Code Approvals Getting Started Appliance LocationDraft Wall Control ThermostatNegative Pressure Inspect Appliance & Components and Pre-Use Check List Mt. Vernon Pellet Stove AE Fire SafetyTools And Supplies Needed 76-152mm Adapter To 6 in 76-152mm Offset Adapter 3Dimensions and ClearancesAppliance Dimensions Exception for Horizontal Installations Hearth Pad Requirements UL and ULC4Vent Information Venting Termination Minimum RequirementsDo not Terminate Vent Termination must exhaust above air inlet elevationMt. Vernon Pellet Stove AE Chimney and Exhaust Connection Equivalent Feet of PipeExample of 3 Elbow-Rear Vent Termination Calculation See FigureMt. Vernon Pellet Stove AE Pipe Selection Chart Altitude in Thousands of Feet5Venting Systems AlcoveMt. Vernon Pellet Stove AE Through The Wall Straight OutDegree Vertical Interior Typical Installation Through The Wall & Vertical ExteriorMt. Vernon Pellet Stove AE Masonry Alternate Masonry6Mobile Home Installation Outside Air Kit Instructions 7Appliance Set-UpLeg Leveling System Mt. Vernon Pellet Stove AE Top Vent Adapter Installation Adapter InstallationInstalling the Top Vent Adapter Rear Vent and Rear Vent to Top VentPiece LOG SET Installation Back Side of Wall Control with Cover Off Operating Instructions Fuel Size, Material and StorageStarting Your First Fire See Wall Control Thermostat ManualFor detailed operating instructions Battery Back-up System Optional Ignition CyclesStart-Up Auto / Man L, ML, M, MH, HAuto-Clean Auto / Man L, ML, M, MH, H Cont’dShutdown Additional Screen MessagesMt. Vernon Pellet Stove AE Quick Start Guide Wall Control for ReferenceSetting Comfort Level Mt. Vernon Pellet Stove AE Quick Start Guide Cont’dMt. Vernon Pellet Stove AE Frequently Asked Questions Issues SolutionsError Message Possible Cause Corrective ActionQuick Reference Maintenance Chart Cleaning or Inspection10Maintaining & Servicing Your Appliance WeeksCleaning Ash Pan Frequency Types of FuelAlternate Fuel Daily See Disposal of Ashes belowCleaning Heat Exchanger & Drop Tube Mt. Vernon Pellet Stove AE Cleaning the Hopper Cleaning the GlassCleaning Convection Blower Requires No Lubrication Cleaning the Top Vent Adapter if installedHigh Ash Fuel Content Maintenance Preparing Firebox for Non-Burn SeasonConvection Blower Replacement Combustion Exhaust Blower Replacement Reference Materials Component FunctionsPower Supply Thermocouple Drop Tube Vacuum SwitchOverheat Sensor Snap Disc Thermocouple FirepotMt. Vernon Pellet Stove AE Component Locations Left SideMt. Vernon Pellet Stove AE Exploded Drawings Description Part NumberMt. Vernon Pellet Stove AE Mt. Vernon Pellet Stove AE Service Parts and Accessories Item No AccessoriesMt. Vernon Pellet Stove AE TOUCHUP-CSB Item No Mt. Vernon Pellet Stove AE Service And Maintenance Log Date of Service Performed By Description of ServiceDate of Service Performed By Description of Service Mt. Vernon Pellet Stove AE Homeowner’s Notes Mt. Vernon Pellet Stove AE Warranty Policy CONDITIONS, Exclusions & Limitation of LiabilityHearth & Home Technologies Limited Warranty Cont’d T O T O