Hearth and Home Technologies SOHO-CE manual Model Soho-CE, What to do if you smell gas

Page 1

Model:

Soho-CE

WARNING: If the information in these instructions is not followed exactly, a ﬁre or explosion may result causing property damage, personal injury, or death.

•Do not store or use gasoline or other ﬂam- mable vapors and liquids in the vicinity of this or any other appliance.

•What to do if you smell gas

-Do not try to light any appliance

-Do not touch any electrical switch.

Do not use any phone in your building.

-Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

-If you cannot reach your gas supplier, call the ﬁre department.

•Installation and service must be performed by a qualiﬁed installer, service agency, or the gas supplier.

This is a room sealed appliance and no other ventilation is required than what is provided.

Installer’s Guide

Installation and Operation

0063-06

WARNING

HOT! DO NOT TOUCH.

SEVERE BURNS MAY RESULT.

CLOTHING IGNITION MAY RESULT.

Glass and other surfaces are hot during operation and cool down.

• Keep children away.

•CAREFULLY SUPERVISE children in same room as appliance.

•Alert children and adults to hazards of high temperatures.

•Do NOT operate with protective barriers open or removed.

•Keep clothing, furniture, draperies and other combustibles away.

This appliance is not supplied with an integral barrier to prevent direct contact with the ﬁxed glass panel. Do NOT operate the appliance without a protective barrier installed.

Contact your dealer or Hearth & Home Technologies if help is needed to properly install one.

These instructions are only valid if the following country symbol is on the appliance. If this symbol is not present on the appliance, it is necessary to refer to the technical instructions which will provide the necessary information concerning the modiﬁcation of the appliance to the conditions of use for the country.

These instructions are valid for the following countries: GB, IE

Heat & Glo • Soho-CE • 2111-900 Rev. D • 6/07

1

Image 1

Contents What to do if you smell gas Model Soho-CEHomeowner Reference Information CongratulationsTable of Contents Appliance Certiﬁcation Listing and Code ApprovalsNon-Combustible Materials Speciﬁcation Combustible Materials SpeciﬁcationGetting Started Design and Installation ConsiderationsInspect Appliance and Components Tools and Supplies NeededSelecting Appliance Location Framing and Clearances84.1 74.0 118.7 89.2 Clearances Constructing the Appliance ChaseFlue Termination Minimum Clearances Termination LocationsSee .4 for speciﬁc clearances Cm minimum in snow regionsAlcove Applications Flue Table Key Flue Information and DiagramsUse of Elbows Measuring StandardsOne Elbow Minimum Maximum Flue Diagrams Horizontal Termination One Elbow Two Elbows+ H Maximum = 11.9 m Maximum = 4.6 m Two Elbows Minimum + H 2 Maximum Elbow only Not AllowedThree Elbows Minimum Maximum Horizontal Termination Three Elbows+ V 2 + H = Maximum = 11.9 m + H 2 Maximum = 4.6 m V1 = 11.8 m Maximum Vertical Termination No Elbow Two ElbowsTwo Elbows V1 Minimum Maximum V1 + V2 + H Maximum = 11.9 mThree Elbows V1 Minimum H1 + H2 Maximum Vertical Termination Three Elbows+ V2 + H1 + H2 Maximum = 11.9 m Maximum = 4.3 m Pipe Clearances to Combustibles Flue Clearances and FramingWall Penetration Framing Combustible Wall PenetrationInstalling Attic Shield Installing the Ceiling FirestopVertical Penetration Framing Securing and Leveling the Appliance Appliance PreparationAssembly of Flue Sections Installing Flue PipeInstall Support Brackets Attach the First Flue Component to Starting CollarsInstalling the Horizontal Termination Cap Installing Firestops and Horizontal Termination CapFor Horizontal Runs Wall shield ﬁrestops are Required Install Roof Flashing and Vertical Termination Cap Sharp Edges Assembling and Installing Storm CollarGas Pressure Requirements Gas InformationGas Connection Natural Gas Propane Butane G20 G31 G30 G25Electrical Information Electronic Ignition System WiringFacing Material FinishingMantel Projections See for combustible/non-combustible deﬁnitionsClean the Appliance Appliance SetupAccessories Ember PlacementPositioning the Logs Log Assembly LOGS-SOHOCERemoving Glass Assembly Glass AssemblyReplacing Glass Assembly Before Lighting Appliance Operating InstructionsElectronic Ignition Lighting the FireplaceInitial Break-in Procedure Frequently Asked QuestionsAfter Appliance is Lit Symptom Possible Causes Corrective Actions TroubleshootingElectronic Ignition System No transmission, motor Receiver mustMaintaining and Servicing Appliance Maintenance TasksRecommend addition of screen if one is not present Inspect Maintenance TasksVerify no obstructions to airﬂow through the louvers Operating properly. Replace as necessaryAppliance Dimensions Table Appliance Dimension DiagramReference Materials Location CentimeterLog Set Assembly Service Parts List108 SOHO-CE SOHO-CE Service PartsLimited Lifetime Warranty Heat & GLO GAS Appliance Products Limited Lifetime WarrantyImportant operating Contact Information