Hearth and Home Technologies SOHO-CE Gas Information, Gas Pressure Requirements, Gas Connection

Page 22

9 Gas Information

A. Gas Pressure Requirements

Pressure requirements for SOHO-CE fireplaces are shown in Table 1 below.

Two taps are provided on the right hand side of the gas control for a test gauge connection to measure the inlet and outlet pressures. See Section 10: Maintaining and Servicing the Appliance.

The fireplace and its individual shut-off valve must be dis- connected from the gas supply piping system during any pressure testing of the system at test pressures in excess of 60 mbar.

If the fireplace must be isolated from the gas supply pip- ing system by closing an individual shut-off valve, it must be of the handle-less type.

WARNING

Fire Risk

Explosion Risk

High pressure will damage valve.

•Disconnect gas supply piping BEFORE pressure testing gas line at test pressures above 60 mbar.

•Close the manual shutoff valve BEFORE pressure testing gas line at test pressures equal to or less than 60 mbar.

Table 1

B. Gas Connection

Note: Have the gas supply line installed in accordance with local building codes by a qualified installer approved and/or licensed as required by the locality.

Note: Before the first firing of the appliance, the gas supply line should be purged of any trapped air.

Note: Consult local building regulations to properly size the gas supply line leading to the (Rp 1/2 in.) hook-up at the unit.

Incoming gas line should be piped into the valve compart- ment and connected to the ISO 7-Rp 1/2 (BSP Rp 1/2 ) threaded gas inlet connection on the manual shutoff valve.

Leak test all gas line points and the gas control valve prior to and after starting the gas appliance.

WARNING

CHECK FOR GAS LEAKS

Explosion Risk

Fire Risk

Asphyxiation Risk

•Check all fittings and connections.

•Do not use open flame.

•After the gas line installation is complete, all connections must be tightened and checked

for leaks with a commercially-available, non- corrosive leak check solution. Be sure to rinse off all leak check solution following testing.

Fittings and connections may have loosened during shipping and handling.

 

Natural Gas

Propane

Butane

Natural Gas

 

(G20)

(G31)

(G30)

(G25)

 

 

 

 

 

Inlet Pressure

20mbar

37 or 50mbar

30 or 50mbar

25mbar

 

 

 

 

 

Manifold Pressure

4.6-9.5mbar

15.8-25mbar

15.5-25mbar

5.4-11mbar

 

 

 

 

 

Gas Rate

.405 m3/h

.134 m3/h

.111 m3/h

.40 m3/h

Max. Input (NETCV)

4.0 kW

3.5 kW

3.6 kW

3.5 kW

 

 

 

 

 

Burner Injector

DMS 50

DMS 58

DMS 61

DMS 50

 

 

 

 

 

Pilot Injector

51

30

30

51

 

 

 

 

 

22

Heat & Glo • Soho-CE • 2111-900 Rev. D • 6/07

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Model Soho-CE What to do if you smell gasCongratulations Homeowner Reference InformationTable of Contents Non-Combustible Materials Specification Listing and Code ApprovalsAppliance Certification Combustible Materials SpecificationInspect Appliance and Components Design and Installation ConsiderationsGetting Started Tools and Supplies NeededSelecting Appliance Location Framing and Clearances84.1 74.0 118.7 89.2 Constructing the Appliance Chase ClearancesSee .4 for specific clearances Termination LocationsFlue Termination Minimum Clearances Cm minimum in snow regionsAlcove Applications Use of Elbows Flue Information and DiagramsFlue Table Key Measuring Standards+ H Maximum = 11.9 m Maximum = 4.6 m Flue Diagrams Horizontal Termination One Elbow Two ElbowsOne Elbow Minimum Maximum Two Elbows Minimum + H 2 Maximum Elbow only Not AllowedThree Elbows Minimum Maximum Horizontal Termination Three Elbows+ V 2 + H = Maximum = 11.9 m + H 2 Maximum = 4.6 m Two Elbows V1 Minimum Maximum Vertical Termination No Elbow Two ElbowsV1 = 11.8 m Maximum V1 + V2 + H Maximum = 11.9 mThree Elbows V1 Minimum H1 + H2 Maximum Vertical Termination Three Elbows+ V2 + H1 + H2 Maximum = 11.9 m Maximum = 4.3 m Wall Penetration Framing Flue Clearances and FramingPipe Clearances to Combustibles Combustible Wall PenetrationInstalling Attic Shield Installing the Ceiling FirestopVertical Penetration Framing Appliance Preparation Securing and Leveling the ApplianceInstall Support Brackets Installing Flue PipeAssembly of Flue Sections Attach the First Flue Component to Starting CollarsInstalling the Horizontal Termination Cap Installing Firestops and Horizontal Termination CapFor Horizontal Runs Wall shield firestops are Required Install Roof Flashing and Vertical Termination Cap Assembling and Installing Storm Collar Sharp EdgesGas Connection Gas InformationGas Pressure Requirements Natural Gas Propane Butane G20 G31 G30 G25Electronic Ignition System Wiring Electrical InformationMantel Projections FinishingFacing Material See for combustible/non-combustible definitionsAccessories Appliance SetupClean the Appliance Ember PlacementLog Assembly LOGS-SOHOCE Positioning the LogsRemoving Glass Assembly Glass AssemblyReplacing Glass Assembly Operating Instructions Before Lighting ApplianceLighting the Fireplace Electronic IgnitionInitial Break-in Procedure Frequently Asked QuestionsAfter Appliance is Lit Electronic Ignition System TroubleshootingSymptom Possible Causes Corrective Actions No transmission, motor Receiver mustMaintenance Tasks Maintaining and Servicing ApplianceVerify no obstructions to airflow through the louvers Inspect Maintenance TasksRecommend addition of screen if one is not present Operating properly. Replace as necessaryReference Materials Appliance Dimension DiagramAppliance Dimensions Table Location CentimeterLog Set Assembly Service Parts List108 SOHO-CE Service Parts SOHO-CELimited Lifetime Warranty Limited Lifetime Warranty Heat & GLO GAS Appliance ProductsContact Information Important operating

SOHO-CE specifications

Hearth and Home Technologies (HHT) has long been a leader in the design and manufacturing of innovative hearth products, and their SOHO-CE model is no exception. This sleek and modern electric fireplace represents a perfect synthesis of aesthetic appeal and functional engineering, specifically tailored for small office/home office (SOHO) settings.

One of the standout features of the SOHO-CE is its Clean Edge design, which allows for a seamless installation that blends effortlessly into any room. This contemporary electric fireplace has a minimalist frame available in various finishes, making it versatile enough to complement different interior styles, from modern to rustic. Its elegant look is well-suited for both residential and commercial spaces, providing an inviting ambiance that enhances the room's overall atmosphere.

The SOHO-CE employs state-of-the-art LED technology to create realistic flame effects. These flames can be adjusted to suit individual preferences, giving users control over the intensity and color. This customization is essential in creating the ideal mood for any occasion, whether it’s a productive workday or a cozy evening at home. In addition, the electric fireplace boasts a safe and efficient heat source with adjustable heat settings, ensuring comfort without compromising safety.

Smart technology integration is another significant characteristic of the SOHO-CE. It can be controlled via a user-friendly app, allowing for remote operation right from a smartphone or tablet. This feature is particularly beneficial for those who want to set the fireplace to a specific schedule, ensuring their space is warm and inviting upon arrival.

In terms of energy efficiency, the SOHO-CE stands out with its eco-friendly operation. As an electric fireplace, it eliminates the need for venting and reduces the emission of pollutants, making it a responsible choice for the environment. It also offers the convenience of heating only when necessary, reducing energy consumption.

Durability is built into the SOHO-CE’s design, featuring high-quality materials that ensure longevity and performance. This electric fireplace is also easy to maintain, with no need for chimneys or flue cleaning. Overall, Hearth and Home Technologies' SOHO-CE is a remarkable addition to any SOHO setting, marrying functionality with style for an exceptional user experience. Whether for work or leisure, this electric fireplace elevates any space.
Top Page Image Contents