Hearth and Home Technologies CB1200-B owner manual Classic BAY 1200 Pellet Stove

Page 1

R

CLASSIC BAY 1200 PELLET STOVE

Owner’s Manual

Installation and Operation

Model:

CB1200-B

Tested and	O-T L	Portland
Listed by	O-T L	Oregon USA

CUS

OMNI-Test Laboratories, Inc.

NOTICE

DO NOT DISCARD THIS MANUAL

• Important operating and	• Read, understand and	• Leave this manual with
maintenance instruc-	follow these instruc-	party responsible for use
tions included.	tions for safe installa-	and operation.
	tion and operation.

DO DISCARDNOT

WARNING

Please read this entire manual before installation and use of this pellet fuel-burning room heater. Failure to follow these instructions could result in property damage, bodily injury or even death.

•Do not store or use gasoline or other ﬂam- mable vapors and liquids in the vicinity of this or any other appliance.

•Do not overﬁre - If any external part starts to glow, you are overﬁring. Reduce feed rate. Overﬁring will void your warranty.

•Comply with all minimum clearances to com- bustibles as speciﬁed. Failure to comply may cause house ﬁre.

WARNING

HOT SURFACES!

Glass and other surfaces are hot during operation AND cool down.

Hot glass will cause burns.

•Do not touch glass until it is cooled

•NEVER allow children to touch glass

•Keep children away

•CAREFULLY SUPERVISE children in same room as ﬁreplace.

•Alert children and adults to hazards of high temperatures.

High temperatures may ignite clothing or other ﬂammable materials.

•Keep clothing, furniture, draperies and other ﬂammable materials away.

CAUTION

Tested and approved for wood pellets and shelled ﬁeld corn fuel only. Burning of any other type of fuel voids your warranty.

CAUTION

Check building codes prior to installation.

•Installation MUST comply with local, regional, state and national codes and regulations.

•Consult local building, ﬁre ofﬁcials or authorities having jurisdic- tion about restrictions, installation inspection, and permits.

www.quadraﬁre.com

7014-082D

September 1, 2008

Image 1

Contents Hot glass will cause burns Classic BAY 1200 Pellet StoveCB 1200 Pellet Stove Testing Lab & Report Number Serial Number Model Mfg DateBehind left side curtain on outside of hopper wall Table of Contents Listing and Code Approvals Fire Safety Design, Installation & Location ConsiderationsGetting Started Appliance LocationInspect Appliance & Components and Pre-Use Check List CB 1200 Pellet Stove Tools And Supplies NeededAppliance Dimensions 3Dimensions and ClearancesCB 1200 Pellet Stove Clearances to Combustibles UL and ULC CB 1200 Pellet Stove Hearth Pad Requirements UL and ULC Exception for Horizontal InstallationsHearth Pad Requirements 4Vent Information CB 1200 Pellet Stove Equivalent Feet of Pipe Pipe Selection ChartExample of 3 Elbow-Rear Vent Termination Calculaton ExampleAlcove 5Venting SystemsDegree Straight OutCB 1200 Pellet Stove Through The Wall Through The Wall & Vertical CB 1200 Pellet Stove VerticalAlternate Masonry Masonry6Mobile Home 7Appliance Set-Up Rear Installation Floor InstallationOutside Air Kit Instructions Rear Vent and Rear Vent to Top Vent Adapter Installation CB 1200 Pellet Stove Top Vent Adapter InstallationInstalling the Top Vent Adapter See FigureInstalled Clip Charred Areas in the Back Installing Logo Nickel OnlyTop Log, Left RightThermostat Installation CB 1200 Pellet Stove Door InstallationTo install door To adjust latchesFuel Size And Material General Operating Information 8Operating InstructionsStarting Your First Fire Feed Rate Adjustment InstructionsButton. See .1, page 22 . When you press Frequently Asked QuestionsCB 1200 Pellet Stove Ignition Cycles Symptom TroubleshootingPossible Cause Corrective Action Page Page Cleaning or Inspection Quick Reference Maintenance Chart10Maintaining & Servicing Your Appliance Frequency Daily Weekly Monthly YearlyCleaning Ash Pan Cleaning Firepot with Cleaning Rod & Firepot ScraperCleaning Heat Exchanger Chambers & Drop Tube Ash Removal from FireboxCleaning Exhaust Path Cleaning Beneath Heat Exchanger Door Latch InspectionCleaning the Hopper Cleaning the Glass Cleaning Exhaust Blower Requires No LubricationPreparing Firebox for Non-Burn Season Frequency Yearly Cleaning the Top Vent AdapterConvection Blower Replacement CB 1200 Pellet Stove High Ash Fuel Content MaintenanceInstall new blower Exhaust Blower Replacement Remove existing blowerRe-install blower to blower housing Replacing Side Glass Screws Glass ReplacementComponent Function & Location Reference MaterialsWiring Harness See .1 below Vacuum SwitchSnap Disc #1 Convection Blower 145F Snap Disc #2 Thermostat Override 200FCB 1200 Pellet Stove Component Locations Glass Size Center 13-7/8 wide x 11 high CB 1200 Pellet Stove Exploded ViewsGlass Size Sides 8 wide x 11 high Nbr Description CB 1200 Pellet Stove Item # Parts Alphabetical Order CB 1200 Pellet Stove Service Parts and AccessoriesItem # Service Parts Alphabetical Order Appliance AccessoriesDate of Service Performed By Description of Service CB 1200 Pellet Stove Service And Maintenance LogCB 1200 Pellet Stove Homeowner’s Notes CONDITIONS, Exclusions & Limitation of Liability CB 1200 Pellet Stove Warranty PolicyHearth & Home Technologies Limited Warranty Cont’d Contact Information