Hearth and Home Technologies CB1200-B CB 1200 Pellet Stove Vertical, Through The Wall & Vertical

Page 14

R

CB 1200 Pellet Stove

C. Vertical

Rain Cap

	Flashing	24 in. (610mm)
		minimum
	Firestop
		Class A Chimney
	Ceiling Support	Connector Adapter
	Ceiling Support	3 in. (76mm)
		3 in. (76mm)
	6 in.	Min.
	6 in.
	(152mm)	Top Vent Kit
	Min.	Top Vent Kit
	Min.
		Clean-out
	Non-combustible Hearth Pad	Cover
	Non-combustible Hearth Pad

We recommend a minimum of 60 in. (1524mm) vertical, however above the eave is preferred.

Both installations are approved for mobile home installations. Must use 3 or 4 inch (76 to 102mm) “L” or “PL” Listed pellet venting or listed double wall pipe and Quadra-Fire out- side air kit in mobile homes. Single wall pipe is approved for residential installations only.

Figure 14.1

D. Through The Wall & Vertical

	Rain Cap
Flashing	24 in. (610mm)
	Minimum
2 in. (51mm) Minimum	Support Bracket
	Support Bracket
	every 60 in. (1524mm)

6 in. (152mm)
Minimum	Wall Thimble
	Wall Thimble
	Tee
	Clean-out Cover

Non-Combustible Hearth Pad

Figure 14.2

Page 14

7014-082D

September 1, 2008

Image 14

Contents Classic BAY 1200 Pellet Stove Hot glass will cause burnsBehind left side curtain on outside of hopper wall Testing Lab & Report Number Serial Number Model Mfg DateCB 1200 Pellet Stove Table of Contents Listing and Code Approvals Getting Started Design, Installation & Location ConsiderationsFire Safety Appliance LocationCB 1200 Pellet Stove Tools And Supplies Needed Inspect Appliance & Components and Pre-Use Check List3Dimensions and Clearances Appliance DimensionsCB 1200 Pellet Stove Clearances to Combustibles UL and ULC Hearth Pad Requirements Exception for Horizontal InstallationsCB 1200 Pellet Stove Hearth Pad Requirements UL and ULC 4Vent Information Example of 3 Elbow-Rear Vent Termination Calculaton Pipe Selection ChartCB 1200 Pellet Stove Equivalent Feet of Pipe Example5Venting Systems AlcoveCB 1200 Pellet Stove Through The Wall Straight OutDegree CB 1200 Pellet Stove Vertical Through The Wall & VerticalMasonry Alternate Masonry6Mobile Home Outside Air Kit Instructions Rear Installation Floor Installation7Appliance Set-Up Installing the Top Vent Adapter CB 1200 Pellet Stove Top Vent Adapter InstallationRear Vent and Rear Vent to Top Vent Adapter Installation See FigureInstalled Clip Top Log, Left Installing Logo Nickel OnlyCharred Areas in the Back RightTo install door CB 1200 Pellet Stove Door InstallationThermostat Installation To adjust latches8Operating Instructions Fuel Size And Material General Operating InformationFeed Rate Adjustment Instructions Starting Your First FireCB 1200 Pellet Stove Ignition Cycles Frequently Asked QuestionsButton. See .1, page 22 . When you press Possible Cause Corrective Action TroubleshootingSymptom Page Page 10Maintaining & Servicing Your Appliance Quick Reference Maintenance ChartCleaning or Inspection Frequency Daily Weekly Monthly YearlyCleaning Heat Exchanger Chambers & Drop Tube Cleaning Firepot with Cleaning Rod & Firepot ScraperCleaning Ash Pan Ash Removal from FireboxCleaning the Hopper Cleaning the Glass Cleaning Beneath Heat Exchanger Door Latch InspectionCleaning Exhaust Path Cleaning Exhaust Blower Requires No LubricationCleaning the Top Vent Adapter Preparing Firebox for Non-Burn Season Frequency YearlyCB 1200 Pellet Stove High Ash Fuel Content Maintenance Convection Blower ReplacementRe-install blower to blower housing Exhaust Blower Replacement Remove existing blowerInstall new blower Glass Replacement Replacing Side Glass ScrewsReference Materials Component Function & LocationSnap Disc #1 Convection Blower 145F Vacuum SwitchWiring Harness See .1 below Snap Disc #2 Thermostat Override 200FCB 1200 Pellet Stove Component Locations Glass Size Sides 8 wide x 11 high CB 1200 Pellet Stove Exploded ViewsGlass Size Center 13-7/8 wide x 11 high Nbr Description CB 1200 Pellet Stove CB 1200 Pellet Stove Service Parts and Accessories Item # Parts Alphabetical OrderItem # Service Parts Alphabetical Order Accessories ApplianceCB 1200 Pellet Stove Service And Maintenance Log Date of Service Performed By Description of ServiceCB 1200 Pellet Stove Homeowner’s Notes CB 1200 Pellet Stove Warranty Policy CONDITIONS, Exclusions & Limitation of LiabilityHearth & Home Technologies Limited Warranty Cont’d Contact Information