Hearth and Home Technologies CB1200-B CB 1200 Pellet Stove Clearances to Combustibles UL and ULC

Page 8

R

CB 1200 Pellet Stove

B. Clearances to Combustibles (UL and ULC)

Alcove Installation	Inches	Millimeters
Minimum Alcove Height	44	1117

A

B

C

C

Minimum Alcove Width	40-1/2	1029
Maximum Alcove Depth	36	915
Minimum Alcove Side Wall	6	152
Top of Unit to Combustibles	12-1/2	318

Straight Back Against			Inches	Millimeters
Wall
A		Back Wall to Appliance	2	51
B		Side Wall to Appliance	6	152

Corner Installation			Inches	Millimeters
C		Walls to Appliance	2	51

Installations with:

3 to 3 inch Top Vent Adapter and

3 to 6 inch Offset Adapter Kit

WARNING

Fire Risk.

Comply with all minimum clearances to combustibles as speciﬁed.

Failure to comply may cause house ﬁre.

NOTE:

•Illustrations reﬂect typical installations and are FOR DESIGN PURPOSES ONLY.

•Illustrations/diagrams are not drawn to scale.

•Actual installation may vary due to individual design preference.

D	F
	F
	E

G

G

Vertical Installation		Inches	Millimeters
D	Back Wall to Flue Pipe	3	76
E	Side Wall to Top	6	152
F	Back Wall to Appliance	7.5	191

Corner Installation		Inches	Millimeters
G	Walls to Appliance	2	51

Page 8

7014-082D

September 1, 2008

Image 8

Contents Classic BAY 1200 Pellet Stove Hot glass will cause burnsBehind left side curtain on outside of hopper wall Testing Lab & Report Number Serial Number Model Mfg DateCB 1200 Pellet Stove Table of Contents Listing and Code Approvals Design, Installation & Location Considerations Fire SafetyGetting Started Appliance LocationCB 1200 Pellet Stove Tools And Supplies Needed Inspect Appliance & Components and Pre-Use Check List3Dimensions and Clearances Appliance DimensionsCB 1200 Pellet Stove Clearances to Combustibles UL and ULC Hearth Pad Requirements Exception for Horizontal InstallationsCB 1200 Pellet Stove Hearth Pad Requirements UL and ULC 4Vent Information Pipe Selection Chart CB 1200 Pellet Stove Equivalent Feet of PipeExample of 3 Elbow-Rear Vent Termination Calculaton Example5Venting Systems AlcoveCB 1200 Pellet Stove Through The Wall Straight OutDegree CB 1200 Pellet Stove Vertical Through The Wall & VerticalMasonry Alternate Masonry6Mobile Home Outside Air Kit Instructions Rear Installation Floor Installation7Appliance Set-Up CB 1200 Pellet Stove Top Vent Adapter Installation Rear Vent and Rear Vent to Top Vent Adapter InstallationInstalling the Top Vent Adapter See FigureInstalled Clip Installing Logo Nickel Only Charred Areas in the BackTop Log, Left RightCB 1200 Pellet Stove Door Installation Thermostat InstallationTo install door To adjust latches8Operating Instructions Fuel Size And Material General Operating InformationFeed Rate Adjustment Instructions Starting Your First FireCB 1200 Pellet Stove Ignition Cycles Frequently Asked QuestionsButton. See .1, page 22 . When you press Possible Cause Corrective Action TroubleshootingSymptom Page Page Quick Reference Maintenance Chart Cleaning or Inspection10Maintaining & Servicing Your Appliance Frequency Daily Weekly Monthly YearlyCleaning Firepot with Cleaning Rod & Firepot Scraper Cleaning Ash PanCleaning Heat Exchanger Chambers & Drop Tube Ash Removal from FireboxCleaning Beneath Heat Exchanger Door Latch Inspection Cleaning Exhaust PathCleaning the Hopper Cleaning the Glass Cleaning Exhaust Blower Requires No LubricationCleaning the Top Vent Adapter Preparing Firebox for Non-Burn Season Frequency YearlyCB 1200 Pellet Stove High Ash Fuel Content Maintenance Convection Blower ReplacementRe-install blower to blower housing Exhaust Blower Replacement Remove existing blowerInstall new blower Glass Replacement Replacing Side Glass ScrewsReference Materials Component Function & LocationVacuum Switch Wiring Harness See .1 belowSnap Disc #1 Convection Blower 145F Snap Disc #2 Thermostat Override 200FCB 1200 Pellet Stove Component Locations Glass Size Sides 8 wide x 11 high CB 1200 Pellet Stove Exploded ViewsGlass Size Center 13-7/8 wide x 11 high Nbr Description CB 1200 Pellet Stove CB 1200 Pellet Stove Service Parts and Accessories Item # Parts Alphabetical OrderItem # Service Parts Alphabetical Order Accessories ApplianceCB 1200 Pellet Stove Service And Maintenance Log Date of Service Performed By Description of ServiceCB 1200 Pellet Stove Homeowner’s Notes CB 1200 Pellet Stove Warranty Policy CONDITIONS, Exclusions & Limitation of LiabilityHearth & Home Technologies Limited Warranty Cont’d Contact Information