State Industries
A B C D E F 100
instruction manual
General Safety
Troubleshooting
Install
Fault and Warning Conditions
Warranty
Maintenance
Temperature Regulation
Safety
Power Vent
Service
Blower Prover Switch
Page 4
GENERAL SAFETY
4
Page 3
Page 5
Image 4
Page 3
Page 5
Contents
Whenever maintenance adjustment or service is required
197836-000
Safe INSTALLATION, USE and Service
Important Definitions
General Safety
General Safety
Table of Contents
Introduction
Replacement Parts and Deliming Products
GET to Know Your Water Heater GAS Models
Installation Considerations
Rough-In-Dimensions
Recovery capacity based on 96% thermal efficiency
All models Maximum Supply Pressure 14 inches W.C .48kPa
Directly BELOW. Keep Clear of ALL Obstructions
Water Piping Mixing Valve Usage
Facts to Consider About the Location
Insulation Blankets
Combustion AIR and Ventilation
Appliances in Unconfined Spaces
Appliances in Confined Spaces
ALL AIR from Inside Buildings See
ALL AIR from Outdoors See Figures 7, 8
Installing the NEW Water Heater
Chemical Vapor Corrosion
Water Piping
Closed Water Systems
Temperature-Pressure Relief Valve
Valve and Pipe Insulation if supplied
High Altitude Installations
Gas Piping
Filling the Water Heater
Sediment Traps Venting
Vent Pipe Termination
Canadian Power Vent
Power Vent
Vent Hoods MAY be Extremely HOT During Operation
Direct Vent
Canadian Direct Vent
Planning the Vent System
Installations
Condensate
Installation of Vent System
Vent Terminal INSTALLATION, Sidewall
Sequence of INSTALLATIONS, a
Direct Vent Terminal Installation Important
Vertical Vent Terminal Installation
Installation Sequence
Vent Terminals Supplied with Heater Must be Used
Installation of Vent SYSTEM, Sidewall
Installation of Vertical Vent System
Concentric Vent Installation
KIT Components
Safety Considerations
Installation Procedure 1 Roof TERMINATION, see Figure C
Procedure 2 Side Wall TERMINATION, see Figure F
Figure F
MULTI-CONCENTRIC Vent Terminations
Figure g
Vent Pipe Preparation
Step B
Step E
Step F
Step G
Blower Prover Switch
Blocked Exhaust Switch
Blocked Intake Switch
ON/OFF Switch
Power Vent Wiring Schematic Figure
ON/OFF Switch
Do not try to light the burner by hand
What to do if YOU Smell GAS
Do not TRY to Light the Burner by Hand
Temperature Regulation
HI Limit Switch E.C.O
Using the Electronic Controller
Overview
Action
Operating States
Display Action
Fault and Warning Conditions
Access to the Current Fault or Warning
Changing the Display Units
Display
Viewing the Fault History
Viewing Information About the Heater
Start UP Conditions
For Your Information
Operational Conditions
Periodic Maintenance
Burner Cleaning
Venting System Inspection
Burner Operation and Inspection
Anode ROD Inspection
Temperature-Pressure Relief Valve Operation
Draining
Service
Leakage Checkpoints
Troubleshooting Guidelines
Problems
Page
Page
Limited Warranty
Top
Page
Image
Contents