Chamberlain WD962KD Battery Backup, Operating Instructions, Orange LED, Green LED, Red Led

Page 34

Battery Backup

OPERATING INSTRUCTIONS

1.Test the installed battery with the motor unit.

To test the battery, disconnectthe motor unit power cord from the electrical outlet.

•A solid orange LED indicates the battery is operating on battery power..

•A flashing orange LED with beep indicates the unit is

operating on battery power and that the battery charge is low..

°To test the battery is functioning properly, open and close the garage door.

°Re-connect the motor unit power cord back into the electrical outlet.

,Verify that the green LED is flashing on the BBU (indicates that the battery is now charging)

• Test completed..

2.Charge the battery.

•Battery will take 24 to 48 hours to fully charge.

A fully charged battery supplies 12V DC to the motor unit for one to two days of normal operation during an electrical power outage.. If the battery voltage drops too low, the batteries will disconnect and the motor unit witi no longer operate under battery power..

After the electricaf power has been restored, the battery will recharge within 48 hours. Under normal usage batteries wilt last 3 to 5 years_

To obtain maximum battery life and prevent damage, disconnect the battery when motor unit is unplugged for an extended period of time.

NOTE: Door operation may be limited until battery is fully charged.. The motor unit's lights will not turn on during battery mode..

To reducethe risk of FIREor INJURYto persons:

•DisconnectALL electricand batterypower BEFORE performingANYserviceor maintenance.

°Use onlyChamberlainpart #4IA6357-!for replacement battery_

•Do NOTdisposeof batteryin fire. Batterymay explode. Checkwith focalcodesfor disposalinstructions.

Batlery Slalus LED

NOTE: LED is most visible with worklight off,

GREEN LED:

All systems are normal

•A solid LED light indicates the battery is fully charged, o A flashing LED indicates the battery is being charged°

NOTE: Battery does not have to be fully charged to operate the motor unit_,

ORANGE LED:

The motor unit has lost power and is operating off of the battery.

°A solid LED with beep, sounding approximately every 2 seconds, indicates the motor unit is activating the door and is operating off of the battery.

-A flashing LED with beep, sounding every 30 seconds, indicates battery is low.

•Once the power is restored the battery will recharge.. This is indicated by a flashing green LED..

RED LED:

•If a red LED remains on when the power is restored, and is accompanied by a beep sounding every 30 seconds, please call for service.,

•To obtain maximum battery life and prevent damage, also disconnect the battery if you unplug the motor

unit while on vacation or any other extended period of time..

34

Page 33 Page 35
Image 34
Page 33 Page 35
Contents Garage Door Opener For Residential Use OnlyService Warranty Adjustment 28.30Accessories Safety Symbol and Signal Word ReviewOne-Piece Door To preventpossibleSERIOUSINJURYor Death Preparing your garage doorSectional Door Tools neededDoor Installation Sectional Door InstallationsPlanning ONE-PIECEDOOR Installations ONE-PIECEDOOR with TrackCurved Door Assembly Hardware Installation HardwareAssembly Step t Assemble the Rail and Install the TrolleyAssembly Step Nut3Install the Belt and Atach the Belt Cap RetainerReadandfollowall Installationwarningsand Instructions INSTALLATllONSeE the Tension Installation Step t 0cmMNSTALLATBON Step Wall Header Bracket InstallationCeiling Header Bracket Installation Knstal# the Header BracketMHSTALLATION Step ONE-PIECEDOOR Without Track UHSTALLATaOH StepPosition the Opener Top of the door should be level with the topIhstallatiion Step Hang the OpenerUse tacks or staples to permanently attach entrapment Outside Keylock Accessory ConnectionsBNSTALLATiON Step Mounting If \1UtNISTALLATilON Step Install the Battery BackupDONOTusebulbs largerthan Ioow ONLYuseA19 sizebulbs Attach the Emergency Release Rope MNSTALLATl!OH StepHandle MNSTALLATmON Step t Elec*rical RequirementsInstall The Protector System Safety Sensors Important Information about Safety Reversing SensorWall installation Figures 2 Installing the BracketsGarage door track installation preferred Floor installation FigureAligning the Safety Reversing Sensors Mounting and Wiring the Safety Reversing SensorsTroubleshooting the Safety Reversing Sensors Sectional Doors Bnstallation Step tFasten he Door Bracket Wood DoorsONE-PIECE Doors GarageConnect Door Arm to Trolley UNSTALLATmN StepSectional Doors only Assemble the Door Arm Adjustment Step Doora,desiredlllAdjustment Step Se**ing the ForceTest Test the Safety Reversal SystemTest The Protector System s Safety Sensors Repeat the tesLReadandfollowallwarningsand Instructions Using Your Garage Door OpenerAlwayskeepgaragedoorproperlybalanced Additional feature when used with Light featureLock feature Button hand-heM remoteCare Of Your Opener Maintenance ScheduleRemote Control Battery Once a MonthOrange LED Battery BackupOperating Instructions Green LEDMy remotes will not activate the door My lights will not turn off when door is openHaving a Problern? TroubHeshooting My motor unit hums brieflySymptom LED is not lit on door control Diagnostic CharfPossible RPM sensor failure. Unplug to reset Symptom RPM Sensor = Short travel 6-815-20 cmButton To Add or Reprogram a Hand.held Remote ControlErase All Codes From Motor Unit Memory 315 MHzUsing the Learn Button Using the Motion Detecting Control 7o Add, Reprograrn or Cange a Keyless EnEry PINKEY Part Installation ParisDescription KEY Part NO. no Motor Unit Assembly PartsKEY Part Description 760CB 8808CB 8810CB 41A5281 Button Mini-Remote Control with SECURITY,I77020BOutside Quick Release Foot 3 m Rail ExtensionHotes Page Chamberlain Service is On Call OUR Large Service Organization Spans America

WD962KLD, WD962KD specifications

The Chamberlain WD962KD and WD962KLD are powerful garage door opener models designed to provide homeowners with advanced technology, convenience, and reliability. Both models come equipped with smart features that make them stand out in the market.

One of the primary features of the WD962KD and WD962KLD is the powerful 1.25 HP motor. This robust motor ensures that even the heaviest garage doors can be opened and closed smoothly without straining the system. The WD962KLD model, in particular, features a DC motor, which not only offers silent operation but also enhances energy efficiency.

Both garage door openers are equipped with Chamberlain's patented MAX Lift Power System. This innovative technology delivers optimal lifting force and steady performance, making the opening and closing cycle faster and more efficient. The models are compatible with various types of garage doors, including sectional, one-piece, and up-and-over doors, providing versatility to suit different homeowners' needs.

Security is a major concern for homeowners, and Chamberlain addresses this with its advanced security features. The WD962KD and WD962KLD come with the MYQ technology, allowing users to monitor and control their garage door from anywhere using their smartphones. The app notifies users about the door's status in real time, providing peace of mind.

Another essential characteristic is the built-in battery backup feature. This ensures that even during power outages, homeowners can still operate their garage doors without hassle. The WD962KLD model goes one step further with its integrated lighting system that illuminates the garage area, enhancing safety and visibility when entering or exiting.

Installation is made easy with the included Quick-Install bracket system, which simplifies the setup process. The smooth operation is further complemented by the silent operation chain drive, ensuring minimal noise during usage, which is perfect for homes that are attached to the garage.

Furthermore, both garage door openers come with remote controls featuring a range of up to 1500 feet, enabling users to open their garage door from a significant distance. The keypad entry system offers an added layer of convenience and security, allowing for keyless access.

In summary, the Chamberlain WD962KD and WD962KLD garage door openers combine advanced technologies and user-friendly features to deliver a premium experience. With robust motors, smart technology, enhanced security options, and easy installation, these models are an excellent choice for homeowners looking to upgrade their garage door systems.
Top Page Image Contents