Frymaster Super Marathon Series manual Adjusting the Pilot Flame, Replacing Fryer Components

Page 11

1.6 Adjusting the Pilot Flame

1.Remove the cover shown in the illustration below to access the pilot flame adjustment screw in the gas valve.

Pilot adjustment locations on CE gas valves (left) and non-CE gas valves (right).

2.Using a small, flat-tipped screwdriver, turn the pilot flame adjustment screw counterclockwise to increase the length of the flame or clockwise to decrease the length of the flame. Adjust the flame to a length of 1-½ inches (38 mm).

3.Reinstall the pilot flame-adjustment cover.

4.Five-tube millivolt fryers: Adjust the trailing pilot (adjustment valve located on the burner manifold) until a 1-½ inch (38 mm) flame is obtained.

1.7 Replacing Fryer Components

1.7.1 Replacing the Operating Thermostat

1.Drain the fryer and turn the gas off.

2.Remove the thermostat knob by pulling straight out on the knob with a firm, steady pull.

3.Disconnect the wires from the thermostat.

4.Remove the two mounting screws to release the thermostat control from its mounting bracket.

5.Remove the screws and clamp that secure the thermostat bulb to the frypot. Remove spring from bulb and reinstall on replacement thermostat bulb.

1-6

Image 11
Contents MAY Hour Service HotlineSuper Runner and Super Marathon Series Page Iii Table of Contents Parts List CE only Altitudes of 2000 feet or less Functional DescriptionNON-CE Altitudes of 2000 feet or less Thermostats Pilot Ignition SystemCleaning the Gas Valve Vent Tube Accessing Fryers for ServicingCalibrating the Operating Thermostat Check Burner Manifold Pressure Replacing the Operating Thermostat Adjusting the Pilot FlameReplacing Fryer Components Replacing the Operating Thermostat Replacing the Frypot Replacing the High-Limit ThermostatPilot Failures Troubleshooting and Problem IsolationAutomatic Pilot Dropout Check Complete System CheckSystem Resistance Check Pilot Fails to Light Improper Burner Functioning Filtration Problems Leaking Current Production Units with Honeywell Gas Valve Non-CE Wiring DiagramsCurrent Production Units with Honeywell Gas Valve CE Current Production Units with Robertshaw Gas Valve After May Optional UFF Filtration Wiring DiagramChannel, Base- Front & Rear Non-Filtration Single Fryers Cabinetry Components, Single FryersSide Panel, Right Suff Base Components- SM Series With Suff FiltrationSide Panel, Left Panel, Outer Door- SM20G Assembly 106-2482SP Door Assembly ComponentsAdditional Single Fryer Base Channel Components Cabinetry Components, Multi-Battery Frying SystemsBase Channel, Front & Rear- SM220G, SM50G See .1 For Fluecap, SM20/20/50G AccessoriesDean Millivolt GAS Fryers Parts List Thermostat, Sunne Use 807-1692 for CE 1 SM220 and SM20/20/~ Systems Frypot and Burner System ComponentsFlue Assembly- SM20G SR Series, SM35G, SM40G and SM50G Systems Shield, Burner Heat- SR52G, SM50 Burner, Right- SR38G, SR42G, SM35G, SM40GBurner, Center- SR38G, SR42G, SM35G, SM40G Burner, Left- SR38G, SR42G, SM35G, SM40G106-0954SPFlue Assembly- SM35G, SM40G 25 106-1742SPFlue Assembly- SR52G, SM50GFlue Assembly- SR38G 106-0696SPFlue Assembly- SR42GSM80G Shown 3 SR62, SM60G and SM80G SystemsFrypot- S/S- SM60G, SR62G Use 823-3511SP for SM160G Valve, Trailing Pilot- SM60G, SM80G, SR62G adjustment valveFrypot- M/S- SM80G Prior To 10/99 obsolete use Flue Assembly- SM60G, SR62G Flue Assembly- SM80GOil Drain Manifold Componets Drain Valve Components Oil Drain Manifold, Drain Flush and Drain Valve ComponentsPlace Over Flush Oil Drain Line 2 3 Oil Drain Manifold, Drain Flush & Drain Valve ComponentsOil Return Manifold Components Fryers with 1½ Drains Oil Return Manifold Components810-0051 200-1143 809-0877 106-2568SP Not Illustrated Oil Return Manifold Components Fryers with 3 Drains Oil Return and Oil Flush Components Fryers with 1½ Drains Oil Return and Oil Flush ComponentsOil Suction Start Fitting Microswitch Bracket Assembly, Oil ReturnOil Return and Oil Flush Components Fryers with 3 Drains Suction Manifold Assembly Oil Suction Assembly1 SM50 and SM60 Series Fryers Except Ihop Under Fryer Filter UFF Components2 SM50 Series Fryers, Ihop UFF 50 with Filter Leaf 3 SM80 Series Fryers 1 SM50 Series Fryers Single Under Fryer Filter Suff Components2 SM60 and SM80 Series Fryers This page Intentionally Left Blank Service Hotline