Frymaster E4 manual Contactor Boxes

Page 62

8.4.2 Contactor Boxes cont.

ITEM PART #

COMPONENT

1106-6124 Box Assembly, FPRE Left Contactor

2106-6125 Box Assembly, FPRE Right Contactor

3106-6288 Box Assembly, Single Foot Print Contactor

4807-0064 Transformer, 480V/120V 150VA

5807-2284 Contactor, 24V 50 Amp Mechanical

6810-1202 Contactor, 24V 40 Amp Mechanical

7807-2434 Relay, Shunt 24V Coil 18 Amp

8807-1683 Relay, Power 12 VDC

9807-0012 Relay, Tilt 18 Amp ⅓ HP 24V Coil

10807-0922Holder, Bus Fuse

11807-2278Fuse, 20 Amp

12231-1135 Cover, RE Left Hand

13232-1135 Cover, RE Right Hand

14230-1377 Cover, RE Single Foot Print

*231-0811 Bracket, Left Hand Contactor Box Mounting RE

*232-0811 Bracket, Right Hand Contactor Box Mounting RE

*WIR0751 Wire Assembly, Filter Shunt Relay

*WIR0726 Wire Assembly, Hood Relay

*WIR0712 Wire Assembly, Latch and Hood Relay

*Not illustrated.

8-13

Page 61 Page 63
Image 62
Page 61 Page 63
Contents
Hour Service Hotline ManualPage Canada RE Series Marine Electric Fryers Operator Troubleshooting Iii Safety Information GeneralController Information Shipping Damage Claim ProcedureService Information Introduction Power Requirements Page Dimensions and Weights Single Fryer with filterEquipment Setup and Shutdown Procedures RE Series Marine E4 Electric Fryers Operating InstructionsDescription Introduction Do not cancel the melt-cycle mode if using solid shortening Controller Operating InstructionsDisabling or Enabling the MELT-CYCLE Cancel Switch RE Series Marine E4 Electric Fryers Filtration Instructions Inspect O-Rings Screen Filter Paper Open valve by Rotating the handle 90º Page Draining and Disposing of Waste Oil RE Series Marine E4 Electric Fryers Preventive Maintenance Page Annual/Periodic System Inspection FryerBuilt-In Filtration System RE Series Marine E4 Electric Fryers Operator Troubleshooting Problem Probable Causes Corrective Action Troubleshooting Control and Heating ProblemsProblem Filtration Problems StartProblem Replacing a Remote Digital Controller Replacing Component Box ComponentsReplacing a High-Limit Thermostat Replacing a Temperature Probe Replacing a Heating Element Page Replacing Contactor Box Components Replacing a Frypot Reinstall the drain tube assembly Page Disconnect flexlines indicated by the arrows Replacing the Filter Transformer or Filter Relay Interface Board Diagnostic Chart Diagnostic LED LegendProbe Resistance Chart Probe Resistance ChartWiring Diagram, Simplified RE17 Wiring Diagram, System Wiring Diagram, Contactor Box Wiring Wiring Diagram, Wiring Harness Wiring Diagram, Remote Cable RE Series Marine E4 Electric Fryers Parts List AccessoriesPage Back Panel, Upper Single FPRE117 Page 106-6452 FPRE217 Double Station Fryer Cabinet Assembly, Fpre Electric Double S/S Drain Tube, Left/Right End Short Valve Assembly, Full Vat Drain FPRE217 Drain Valve Assembly and Component Parts Electronics and Wiring Components 8.4.1 Component Boxes Relays are not replaceableComponent Boxes Contactor BoxesContactor Boxes Terminal Blocks Heating Element Assembly and Associated Parts Heating Element Assembly and Associated Parts For other controllers, cables and harnesses see manual Component Box and Filter Pump Wiring Harnesses Page Assembly, Filter Pan Single FPRE117 includes pan and lid FPRE217 Filtration Components Suction Tube Frypot Assembly and Thermostat Oil Return System ComponentsOil Return System Components Oil Disposal Plumbing Wiring Connectors, Pin Terminals, Seals, and Power Cords Component Fasteners Service Hotline
Related manuals
Manual 86 pages 38.42 Kb Manual 2 pages 51.67 Kb Manual 36 pages 37.47 Kb
Top Page Image Contents