Frymaster E4 manual Component

Page 76

8.9Wiring Connectors, Pin Terminals, Seals, and Power Cords cont.

ITEM

PART #

 

 

*807-3834

*106-6530

1807-1068

2807-3232

3807-0158

4807-0156

5807-0159

6807-0875

7807-1067

8807-2078

9807-0157

10807-0155

11807-0160

12807-0804

13816-0675

14816-0676

15816-0667

16816-0668

17816-0669

18816-0670

19816-0671

20816-0672

21816-0673

22816-0674

23826-1341

24826-1342

25807-2518

*Not illustrated.

COMPONENT

Power Cords

Cable, 3-Phase 4-Wire (Fryer Power Cable)

Cord, Filter System Power 220V 15A

Connectors

2-Pin Female

4-Pin Female

6-Pin Female

9-Pin Female

12-Pin Female

15-Pin Female

2-Pin Male

4-Pin Male

6-Pin Male

9-Pin Male

12-Pin Male

15-Pin Male

Universal Mate-N-Lock Seals

4-Pin Wire Seal

4-Pin Interface Connector Seal

6-Pin Wire Seal

6-Pin Interface Connector Seal

9-Pin Wire Seal

9-Pin Interface Connector Seal

12-Pin Wire Seal

12-Pin Interface Connector Seal

15-Pin Wire Seal

15-Pin Wire Seal

Terminal, Female Split Pin (Pkg of 25)

Terminal, Male Split Pin (Pkg of 25)

Plug, Mate-N-Lock (Dummy Pin)

8-27

Page 75 Page 77
Image 76
Page 75 Page 77
Contents
Hour Service Hotline ManualPage Canada RE Series Marine Electric Fryers Operator Troubleshooting Iii Safety Information GeneralService Information Shipping Damage Claim ProcedureController Information Introduction Power Requirements Page Dimensions and Weights Single Fryer with filterEquipment Setup and Shutdown Procedures RE Series Marine E4 Electric Fryers Operating InstructionsDescription Introduction Do not cancel the melt-cycle mode if using solid shortening Controller Operating InstructionsDisabling or Enabling the MELT-CYCLE Cancel Switch RE Series Marine E4 Electric Fryers Filtration Instructions Inspect O-Rings Screen Filter Paper Open valve by Rotating the handle 90º Page Draining and Disposing of Waste Oil RE Series Marine E4 Electric Fryers Preventive Maintenance Page Annual/Periodic System Inspection FryerBuilt-In Filtration System RE Series Marine E4 Electric Fryers Operator Troubleshooting Problem Probable Causes Corrective Action Troubleshooting Control and Heating ProblemsProblem Filtration Problems StartProblem Replacing a Remote Digital Controller Replacing Component Box ComponentsReplacing a High-Limit Thermostat Replacing a Temperature Probe Replacing a Heating Element Page Replacing Contactor Box Components Replacing a Frypot Reinstall the drain tube assembly Page Disconnect flexlines indicated by the arrows Replacing the Filter Transformer or Filter Relay Interface Board Diagnostic Chart Diagnostic LED LegendProbe Resistance Chart Probe Resistance ChartWiring Diagram, Simplified RE17 Wiring Diagram, System Wiring Diagram, Contactor Box Wiring Wiring Diagram, Wiring Harness Wiring Diagram, Remote Cable RE Series Marine E4 Electric Fryers Parts List AccessoriesPage Back Panel, Upper Single FPRE117 Page 106-6452 FPRE217 Double Station Fryer Cabinet Assembly, Fpre Electric Double S/S Drain Tube, Left/Right End Short Valve Assembly, Full Vat Drain FPRE217 Drain Valve Assembly and Component Parts Electronics and Wiring Components 8.4.1 Component Boxes Relays are not replaceableComponent Boxes Contactor BoxesContactor Boxes Terminal Blocks Heating Element Assembly and Associated Parts Heating Element Assembly and Associated Parts For other controllers, cables and harnesses see manual Component Box and Filter Pump Wiring Harnesses Page Assembly, Filter Pan Single FPRE117 includes pan and lid FPRE217 Filtration Components Suction Tube Frypot Assembly and Thermostat Oil Return System ComponentsOil Return System Components Oil Disposal Plumbing Wiring Connectors, Pin Terminals, Seals, and Power Cords Component Fasteners Service Hotline
Related manuals
Manual 86 pages 38.42 Kb Manual 2 pages 51.67 Kb Manual 36 pages 37.47 Kb
Top Page Image Contents