Unified Brands VENTILATION SYSTEMS Air Movement Recordings, Project Name, C. Supply Plenum

Page 30

AIR MOVEMENT RECORDINGS

AIR MOVEMENT RECORDINGS

(Supplement to Ventilator Installation/Start Up Report)

Project Name

	Readings Taken by:
A. ENERGY AIRE HOODS - EXHAUST
	4.	B. FILTER HOODS - EXHAUST
1. Reading No. 1, 2, and 3 are taken at the front	1.	Take Reading No. 1, 2, and 3 on vertical
middle, and back of the intake slot.	centerlines.
2. For 8 foot hood sections and less, take three	2.	Refer to A.2, 3.
[3] readings at each of three [3] locations:
1 foot from each end, and one [1] reading in	C. SUPPLY PLENUM
the middle.	1.	Reading No. 1 only is used.
3. For hood sections over 8 feet in length, take	2.	Take readings on horizontal centerline of grill.
three [3] readings at each of four [4] locations:	3.	Refer to A.2, 3, but only one reading at each
1 foot from each end, and two [2] readings in	location
the middle.
AVTEC INDUSTRIES INC. 1055 MENDELL DAVIS DR.		JACKSON, MS 39272 [888] 994-7636

form no. 14018 1998 AVTEC Industries inc.

27

Image 30

Contents 1055 Mendell Davis Drive Jackson, MS VENTILATION SYSTEMSOPERATORS MANUAL 888-994-7636,fax avtecind.comTABLE OF CONTENTS PERIODIC MAINTENANCE VENTILATOR FEATURES AND ACCESSORIESAir Adjustment Baffle G. Fusible Link Replacement1I. TYPES OF SYSTEMS Installation shall be in accordance with NFPA NOTE Welds must not impede operation of damper Page Page Fig 8a Fig 8b 9.Terminal Block #11 TB-11has three 3 pairs of terminals. The first pair of terminals are low voltage connections for the detergent low level probe. The probe should be installed in the detergent container so that it does not protrude above the top of the detergent pump inlet strainer. fig. #9 This is intended to prevent cavitation of the pump and will advise when the tank needs to be refilled. The probe rods may be cut to facilitate a neat and effective installation Terminal Block Designation For authorized sevice techinician use onlyError! Not a valid link Page VI. OPERATION vac as long as the START Button is depressed a. Fan Start b. Setting the PAWS d. Reviewing The Daily Event Schedule OFF/WASH Page l. Detergent Pump and Tank Refer to fig E. Fire Dampers 1. Fusible Link Type fig. 3. Slot-TypeInternal Air Make-Up D. Grease Collection Receptacle C. PAWS/VCW PANEL - PLUMBING A. PAWS PANEL - ELECTRICALB. VCW PANEL - ELECTRICAL ITEM NOITEM NO D. EVAC DETERGENTE. ELECTRO - MECHANICAL DAMPER DESCRIPTIONITEM NO F. FUSIBLE LINK DAMPERG. HOOD CANOPY AVTEC PART NOFor Exhaust Ventilator Auto-washCleaner Cleaner/DegreaserCleaner/Degreaser UNIQUE, POWERFUL CLEANING FORMULAA. ENERGY AIRE HOODS - EXHAUST AIR MOVEMENT RECORDINGSProject Name B. FILTER HOODS - EXHAUSTPage CALCULATING AND RECORDING AIR MOVEMENT EXHAUSTSUPPLY AVTEC SERVICE AGENCY, CALL OR WRITE TO FOR THE NAME AND LOCATION OF THE NEAREST