Craftsman 917.27224 manual Tractor - Model Number 9t7.272240 Chassis and Enclosures

Page 37

TRACTOR - - MODEL NUMBER 9t7.272240 CHASSIS AND ENCLOSURES

KEY PART

NO. NO.DESCRIPTION

1 174619 Chassis

2176554

317060612 Screw, 3/8-16 x 314

9172542)(418 Dash

10STD533710 Bolt, Carriage 3/8-16x 1

11174996 Panel, Dash, LH

13175256)(010 Panel, Dash, RH

1417490608 Screw Thdrol 3/8-16x 1/2

17172540)(615 Hood Assembly

18126938X BumperHood

20	156437	Plate Batter,/
23	124028X	Bushing Snap
29	19131312	Washer 13138 x 13116 x 12 Gauge

26STD541437 Locknut, Hex, with Insert 3/8-16 UNC

28174948)(418 Grille

29t74944X4t8 Lightbox Dust

30175692X615 Fender/Footrest

31139976 Bracket, Fender/Support

371749(}508 Screw, Thdrol. 5116-18 x 1/2 TYT

38175710 Bracket Asrn Pivot Mower Rear

42172549X999 Lens Lh

43172544X999 Lens Rh

58 174993 Duct Hood

59110436X Bushing, Snap, Split

60STD533707 Bolt Rdhd Sqnk 318-16 UNC x 3/4

64

174997

Dash Lower

74ST0541437 Nut Cmwnlock 3/_-16 UNC

142175702 Plate Reinforcement

143	154966	Bracket Swaybar Chassis
144	176582	Bracket Footrest
145	156524	Rod Pivot Chassis/Hood
154	174679	Bracket Dash Rh
155	174680	Bracket Dash Lh
156	163806	Striker Plate
157	163806	Magnet YTGT
198	162037	parking Brake Bkrt
159	199123)(418	Cupholder Sit BIk
166	164863	HWHDH:-Lo.#13-16 x 3/4
206	170169	Bolt Shoulder 6/16-19

20717670508 Screw Thdrol 5/16-18 x 1/2

20917000612 Scraw Hexwsh Thdr 3/8o16 x 3/4

212 174988

Bracket Pivot Hood

215172543X616 Bumper

NOTE: All component dimensions given in U.S. inches 1 inch = 26.4 rnm

37

Image 37

Contents Icrrftsmrni Safety Rules WarrantyProduct Specifications AssemblyII. Slope Operation General OperationNever run a machine inside a clo= area IV. ServiceMower blades are sharp and can Cancer and birth defects or other repro- ductive harm Ifmachinestopswhilegoinguphill3ASOLINE 3.5 Gallons Product SpecificationsRepair Agreement Customer ResponsibilitiesSeat Steering WheelSlope Sheet Howto SET Upyourtractor Check Battery Tools Required for AssemblyInstall Seat To Removetractor from Carton Unpack CartonAssemble Gaugewheelsto Mower Deck Lower seat into operating position and sit in seatCenter Iocknuts and tighten securely Slide mower under tractor with Lock Ut B BracketLower mower linkage with attachment lift control Be sure belt tension rod is in disen- gaged positionCheck Deck Levelness Checktire PressureCheck for Proper Position of ALL Belts Check Brake SystemRRN Pedal Hourmeter Indicates hours of operation KnowyourtractorHowto Useyourtractor to SET Parking Brake To Adjust Mower Cutting HeightStopping Mower Blades Ground DriveTo Operate Mower To Adjust Gauge WheelsTo Stop Mower Blades To Operate on HillsADD Gasoline To Start EnginePulled out slightly Engine warm up periodPurgetransmission Free.wheellever while the engine is runningMaintenanceschedule Lubrication ChartGeneral Recommendations Before Each USETires BatteryOperator Presence System Blade CareEngine Lubrication To Clean Battery and TerminalsBelts Transaxle Pump FluidClean AIR INTAKE/COOLING Areas Clean AIR ScreenTo Service PRE-CLEANER To Service CartridgeAssembly section of this manual To Install MowerTractor To Remove MowerFRONT-TO-BACK Adjustment SIDE-TO-SIDE AdjustmentRaise mower to its highest position Both Front Links Must be Equal LengthRemove belt from electdc clutch pulley To Adjust BrakeCover Clutch Posin Idler To Replace Mower Blade Drive BeltTransmission REMOVAL/REPLACE- Ment To Adjust Steering Wheel ALIGN- MentTo Replace Motion Drive Belt Front Wheel TOE-IN/CAMBERReplacing Battery To Start Engine with a Weak BatteryTo Attachjumper Cables To Remove CABLES, Reverse OrderTo Adjust Choke Control To Adjust Throttle Control CableTo Adjust Carburetor Preliminary SettingRecheck idle speed. Readjust if necessary Final SettingWise 1 tum Acceleration TestTractor To Clean Battery and TermiEngine OIL CylindersCause Correction Troubleshoongchart ProblemProblem Troubleshooting ChartCause CorrectionOFF CauseSeatswitch TRACTOR-- Model Number Schematic Tractor - Model Number Electrical KEY Part Description TRACTOR-- Model Number ElectricalTRACTOR- -MODELNUMBER917.272240 Chassisandenclosures Tractor - Model Number 9t7.272240 Chassis and Enclosures TRACTOR- -MODEL NUM BER Ground Drive 250 TRACTOR- Model Number Ground DriveTRACTOR- -MODEL Number Steering Assembly TRACTOR-- Model Number 917.272240 Steeringassembly TRACTOR- Model Number Engine Tractor - Model Number Engine KEY Part NO. NO. Description TRACTOR- Model Number Seat AssemblyDescription KEY Part TRACTOR- Model Number DecalsTractor - Model Number Liftassembly 37 123935X Plug Hole 38 17066516 Screw 5/16-18 x TRACTOR-- Model Number LiftassemblyTRACTOR- -MODEL Number Mowerdeck 5116-18 x 5/8 Tractor - Model Number MowerdeckOe oo 032 Ift22 KEY Part NO. no Description Descripon Blower Housing and Baffles Ignitionicharging KEY Part Description Starting System I Engine Controls KEY Part Description NO. no Crankshaft J Exhaustj Exhaust Page Page Page Suggested Guide for Sighting Slopes for Safe Operation Part Canada