Craftsman 917.27224 manual TRACTOR-- Model Number Liftassembly

Page 47

TRACTOR-- MODEL NUMBER 917.272240

LIFTASSEMBLY

KEY	PART
NO.	NO.	DESCRIPTION
1	176263	PlungerAssembly
2	159476	Shaft Assembly, Uft
3	138284	Pin, Groove

4 12000002 E-Ring

519211621 Washer 21/32 x 1 x 21 Gauge

6120183X Bearing, Nylon

7175830 Grip, Handle, Fluted

11	175370	Link, LJft, L.H.
12	175371	Link, Lift, R.H.
13	4939M	Retainer Spdng

15175562 Plate Asm Suspension Front

1673350800 Nut Jam Hex 1/2-13 Unc

17175689 Trunnion Front Susp,

1873800800 Nut Lock wfWsh 1/2-13 Unc

20 163552 Retainer Spring

31176205 Trunion SLIps. Arm.

32175994 Nut Uft Link 7/16-20

36155097 pointer Height Indicat or

37123935X Plug Hole

3817066516 Screw 5/16-18 x 1

4019112410 Washer 11132 x 1-1/2 x 10 Ga

41155098 Indicator Height Silt

49 145212 Nut Hex/Large Lock

5119171416 Washer 17/32 x 7/8 x 16 Ga.

52175378 Arm Suspension Rear LH

53175802 Arm Suspension Rear RH

54175560 PInFlange

NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm

47

Image 47

Contents Icrrftsmrni Assembly WarrantySafety Rules Product SpecificationsII. Slope Operation General OperationMower blades are sharp and can IV. ServiceNever run a machine inside a clo= area Cancer and birth defects or other repro- ductive harm IfmachinestopswhilegoinguphillCustomer Responsibilities Product Specifications3ASOLINE 3.5 Gallons Repair AgreementSlope Sheet Steering WheelSeat To Removetractor from Carton Unpack Carton Tools Required for AssemblyHowto SET Upyourtractor Check Battery Install SeatCenter Iocknuts and tighten securely Lower seat into operating position and sit in seatAssemble Gaugewheelsto Mower Deck Be sure belt tension rod is in disen- gaged position Lock Ut B BracketSlide mower under tractor with Lower mower linkage with attachment lift controlCheck Brake System Checktire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsRRN Pedal Hourmeter Indicates hours of operation KnowyourtractorGround Drive To Adjust Mower Cutting HeightHowto Useyourtractor to SET Parking Brake Stopping Mower BladesTo Operate on Hills To Adjust Gauge WheelsTo Operate Mower To Stop Mower BladesADD Gasoline To Start EngineFree.wheellever while the engine is running Engine warm up periodPulled out slightly PurgetransmissionBefore Each USE Lubrication ChartMaintenanceschedule General RecommendationsBlade Care BatteryTires Operator Presence SystemTransaxle Pump Fluid To Clean Battery and TerminalsEngine Lubrication BeltsTo Service Cartridge Clean AIR ScreenClean AIR INTAKE/COOLING Areas To Service PRE-CLEANERTo Remove Mower To Install MowerAssembly section of this manual TractorBoth Front Links Must be Equal Length SIDE-TO-SIDE AdjustmentFRONT-TO-BACK Adjustment Raise mower to its highest positionTo Replace Mower Blade Drive Belt To Adjust BrakeRemove belt from electdc clutch pulley Cover Clutch Posin IdlerFront Wheel TOE-IN/CAMBER To Adjust Steering Wheel ALIGN- MentTransmission REMOVAL/REPLACE- Ment To Replace Motion Drive BeltTo Remove CABLES, Reverse Order To Start Engine with a Weak BatteryReplacing Battery To Attachjumper CablesPreliminary Setting To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorAcceleration Test Final SettingRecheck idle speed. Readjust if necessary Wise 1 tumCylinders To Clean Battery and TermiTractor Engine OILCause Correction Troubleshoongchart ProblemCorrection Troubleshooting ChartProblem CauseOFF CauseSeatswitch TRACTOR-- Model Number SchematicTractor - Model Number Electrical KEY Part Description TRACTOR-- Model Number ElectricalTRACTOR- -MODELNUMBER917.272240 Chassisandenclosures Tractor - Model Number 9t7.272240 Chassis and Enclosures TRACTOR- -MODEL NUM BER Ground Drive 250 TRACTOR- Model Number Ground DriveTRACTOR- -MODEL Number Steering Assembly TRACTOR-- Model Number 917.272240 Steeringassembly TRACTOR- Model Number Engine Tractor - Model Number Engine KEY Part NO. NO. Description TRACTOR- Model Number Seat AssemblyDescription KEY Part TRACTOR- Model Number DecalsTractor - Model Number Liftassembly 37 123935X Plug Hole 38 17066516 Screw 5/16-18 x TRACTOR-- Model Number LiftassemblyTRACTOR- -MODEL Number Mowerdeck 5116-18 x 5/8 Tractor - Model Number MowerdeckOe oo 032 Ift22 KEY Part NO. no Description Descripon Blower Housing and Baffles Ignitionicharging KEY Part Description Starting System I Engine Controls KEY Part Description NO. no Crankshaft J Exhaustj Exhaust Page Page Page Suggested Guide for Sighting Slopes for Safe Operation Part Canada