Alamo 260, 284, 272 manual

Image 100

Alamo 260, 284, 272 manual

Contents

260/272/284 RHINOROTARY MOWER OPERATOR’S MANUAL To the Owner/Operator/Dealer DealerTelephone Model Number OSHA TRAINING REQUIREMENTS one 1 AEM Mower Safety Practices Video Alamo Group Ag. Division will provide DEALER to CUSTOMER Pre-Delivery/ Operation Instructions PRE-DELIVERY SERVICE CHECK AND ADJUST OR LUBRICATE AS REQUIREDSAFETY ITEMS ATTACHMENTS & INSTALLATIONPage Table of Contents SAFETY SECTIONASSEMBLY SECTION INTRODUCTION SECTION MAINTENANCE SECTION BLADE CARRIER INSTALLATION SEASONAL CLUTCH MAINTENANCEBLADE REMOVAL SLIP CLUTCHPage SAFETY SECTION Safety Section SAFETY SAFETYGENERAL SAFETY INSTRUCTIONS AND PRACTICES OPERATOR SAFETY GENERAL OPERATING SAFETYVISIBILITY CONDITIONS WHEN MOWING GROUND SPEED WHEN MOWING CONNECTION OR DISCONNECTING IMPLEMENT SAFETY WHEN CONNECTING IMPLEMENT DRIVELINEDO NOT USE PTO ADAPTER. Using a PTO adapter can cause ATTACHED CRUSHING HAZARDS WHEN RAISING OR LOWERING IMPLEMENTWHEN UNHITCHING IMPLEMENT TO AVOID CHILDREN FALLING OFF OR BEING CRUSHED BY EQUIPMENT THROWN OBJECTS HAZARDS STOP MOWING IF PASSERSBY ARE WITHIN 300 FEET UNLESSINSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING HIGH GRASS and WEED AREA INSPECTION THROWN OBJECTS HAZARDS CONTINUED STOP mowing when EXCESSIVE VIBRATION occursMOWER OPERATION AVOID MOWING in reverse WHEN MOUNTING AND DISMOUNTING TRACTOR RUN OVER HAZARDSONLY mount or dismount when tractor and moving parts are stopped PTO ENTANGLEMENT HAZARDS ROTATING COMPONENTS CONTINUE to ROTATE after the PTO is shut offPTO SHIELDING DO NOT USE PTO ADAPTER MOWER BLADE CONTACT HAZARDS HIGH PRESSURE OIL LEAK HAZARDS HIGH PRESSURE FLUID LEAKS CAN BE INVISIBLE ELECTRICAL & FIRE HAZARDS EQUIP Tractor with a FIRE EXTINGUISHER TRANSPORTING HAZARDS TOWED MOWERS - ENGAGE TRANSPORT LOCKS AND SAFETY CHAINSWHEN TOWING OR TRANSPORTING EQUIPMENT TRACTOR REQUIREMENTS FOR TOWING OR TRANSPORTING IMPLEMENTS HAZARDS WITH MAINTENANCE OF IMPLEMENT BEFORE PERFORMING SERVICE, REPAIRS AND MAINTENANCE ON THE IMPLEMENTSAFETY SHIELDS, GUARDS AND SAFETY DEVICES INSPECTION DISCONNECT IMPLEMENT driveline from tractor PTO SHAFT PARTS INFORMATION SEE YOUR RHINO DEALER Decal Location Decal Sheets Name 00781352 SAFETY Name 00781326 260 LOGOS TYPEDESCRIPTION Name 00781327 272 LOGOS Name 00781328 284 LOGOS Decal Description SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY Federal Laws and Regulations Employer-Employee Operator RegulationsThis Act Seeks DUTIES INTRODUCTION SECTION Introduction Section INTRODUCTION INTRODUCTION Equipment Specifications Gearbox Rating 130HP130HP Driveline Size KEY OPERATION POINTS Warranty informationOperating Noise Level/Sound Pressure RHINO LIMITED WARRANTY RHINO1020 S Sangamon Ave Gibson City, ILPage ASSEMBLY SECTION Assembly Section ASSEMBLY ASSEMBLYDEALER SETUP INSTRUCTIONS SHIELD ASSEMBLY All Models TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only TAIL WHEEL INSTALLATION Model 260Asm-R-0408 DUAL TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only A-FRAME INSTALLATION Quick Hitch Model A-FRAME INSTALLATION Model DRIVELINE ATTACHMENT AXLE ASSEMBLY TONGUE Pull Type HYDRAULIC OR MANUAL LIFT Model 284 Only WHEELS Model 284 Only Front and Rear Deflectors Standard Equipment Front Rubber Fabric Deflectors Standard EquipmentFront Deflector Figure Asm-0045 Rear Deflector - Figure Asm-R-0044 Front Chain Guards Figure Asm-R-0343 CHAIN GUARDS Optional Equipment - All ModelsRear Chain Guard - Figure Asm-R-0344 NOTE Figure ASM-0038 shows optional spring shock installation CHECK CHAINS Extra EquipmentNOTE 260 and 272 units use a Cat I Kit and 284 Units use a Cat II Kit OFFSET ADAPTER HITCH EXTRA EQUIPMENT Page OPERATION SECTION Operation Section OPERATION OPERATIONRHINO 260/272/284 ROTARY MOWER OPERATION INSTRUCTIONS 1. OPERATOR REQUIREMENTS PERSONAL PROTECTIVE EQUIPMENT PPE Tractor Requirements and Capabilities 2. TRACTOR REQUIREMENTS2.1 ROPS and Seat Belt 2.2 Tractor Safety Devices 2.3 3-Point Hitch 2.6 Power Take Off PTO 2.4 Front End Weight2.5 Drawbar-Pull Type Mower 3. GETTING ON AND OFF THE TRACTOR 3.1 Boarding the Tractor 4. STARTING THE TRACTOR 3.2 Dismounting the TractorEssential Tractor Controls Before starting the tractor ensure the following 5. CONNECTING THE MOWER TO THE TRACTOR 5.1 Connecting Mower-Lift Type 5.2 3-Point Quick Hitch 5.3 Connecting Mower - Lift Type Quick Hitch 5.4 Safety Tow Chain 6. SETTING THE MOWER 6.1 Setting Mower Height- Lift Type - Standard or Quick Hitch NOTE Install optional check chains when there is a problem with the hydraulic 3-Point lift maintaining a set height or when a constant pre-adjusted cut height is required. See Check Chains in the Assembly Section for this accessory 6.2 Connecting the Mower-Pull Type 6.3 Setting Mowing Height-Pull Type 6.4 Setting Deck Pitch 7. DRIVELINE ATTACHMENTLower Horse Power - Better Fuel Efficiency Increase Mulching 7.1 Driveline Length Check “Bottoming Out” Check Procedure Engagement Check Procedure 8. PRE-OPERATION INSPECTION AND SERVICEShorten the driveline profiles as follows OPERATION 8.1 Tractor Pre-Operation Inspection/Service 8.2 Mower Pre-Operation Inspection/Service OPERATION OPERATION OPERATION 8.3 Cutting Component Inspection OPS-U-0031 OPERATION OPERATION OPERATION 8.4 Blade Bolt Inspection Tractor PRE-OPERATION Inspection DO NOT OPERATE an UNSAFE TRACTOR or MOWERTractor ID# Make Rotary Mower PRE-OPERATION Inspection 9. DRIVING THE TRACTOR AND IMPLEMENT 9.2 Brake and Differential Lock Setting 9.1 Starting the Tractor 9.3 Raising the Mower 9.4 Driving the Tractor and Mower 9.5 Crossing Ditches and Steep Inclines 10. OPERATING THE TRACTOR AND IMPLEMENT OPS-R-0022 10.1 Foreign Debris Hazards Raise Mower over solid objects 10.2 Bystanders/Passersby PrecautionsRemove Foreign Material 10.3 Engaging the Power Take Off PTO STOP MOWING IF PASSERSBY ARE WITHIN 300 Feet UNLESS 10.4 PTO RPM and Ground Speed 10.5 Operating the Mower SGM-08 OPERATION INSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING 4. RAISE CUTTING HEIGHT to 6 INCHES minimumSTOP MOWING IF PASSERSBY IS WITHIN 300 FEET UNLESS 11. DISCONNECTING THE MOWER FROM THE TRACTOR 10.6 Shutting Down the Implement OPERATION 12. MOWER STORAGE 13. TRANSPORTING THE TRACTOR AND IMPLEMENT 13.1 Transporting on Public Roadways OPERATION 13.2 Hauling the Tractor and Implement 14. TROUBLE SHOOTING GUIDE ProblemPossible Cause Remedy OPERATION OPERATIONPage MAINTENANCE SECTION Maintenance Section MAINTENANCE MAINTENANCE Lubrication MAINTENANCE MAINTENANCE MAINTENANCE GEARBOX Model 260 TAIL WHEEL ASSEMBLYGEARBOX Model DRIVELINE LUBRICATION LIFT TYPE DRIVELINE & PULL JACKSHAFT SHIELDS CV TYPE DRIVELINE MAIN CV DRIVELINE SAFETY SHIELD NOTE Correct Blade Rotation is counter-clockwise viewed from the top BLADE SERVICINGNOTE Replace Blades in pairs after no more than 1/2” notch wear BLADE SHARPENING BLADE CARRIER REMOVAL BLADE CARRIER INSPECTION BLADE CARRIER INSTALLATION BLADE REMOVAL SLIP CLUTCH SEASONAL CLUTCH MAINTENANCE STORAGE PROPER TORQUE FOR FASTENERS SEGURIDAD SEGURIDADPARTES DE INFORMACIÓN RHINO DISTRIBUIDOR SU A CONTACTE IMPLEMENTO DEL MANTENIMIENTO EL CON RIESGOS CUCHILLAS DE INSPECCIÓNIMPLEMENTO DEL MANTENIMIENTO DE SECCIÓN APROPIADO MANTENIMIENTO O REPARACIÓN SERVICIO, UN TRANSPORTE EN RIESGOS tractor del ADVERTENCIA DE BALIZAS LAS ENCIENDAEQUIPO EL TRANSPORTAR O REMOLCAR AL IRREGULAR FUEGO DE Y ELÉCRTICOS RIESGOS MATAFUEGOS CON EQUIPADO estar debe tractor ElSERVICIOS DE Y GAS DE LÍNEAS ELÉCTRICOS, CABLES DE CERCA TRABAJAR AL ELÉCTRICO CONTACTO POR MUERTE LA O GRAVES LESIONES EVITAR PARA CORTADORA DE CUCHILLAS LAS A CONTACTO DEL RIESGO PRESIÓN ALTA DE HIDRÁULICO ACEITE DE FILTRACION DE RIESGOVISIBLES SER NO PUEDEN PRESIÓN ALTA DE LÍQUIDO DE FILTRACIONES LAS PRESIÓN ALTA DE HIDRÁULICO ACEITE PTO EL POR ENREDO DE RIESGO PTO DE ADAPTADOR UN UTILICE NOPTO LA DE PROTECCIÓN PTO la apagada vez una ROTANDO SIGUEN GIRATORIOS ELEMENTOS LOS TRACTOR DEL BAJAR Y SUBIR AL ATROPELLO DE RIESGOEQUIPO DEL Continuado LANZADOS OBJECTOS DE RIESGO dañadas o dobladas CUCHILLAS las o dañada parte toda REEMPLACEtractor del MOTOR EL Y PTO EL DETENGA reversa en CORTADORA LA OPERAR EVITE LANZADOS OBJECTOS DE RIESGO ARROJADOSmínimo, como PULGADAS 6 CM 15 a CORTE DE ALTURA LA ELEVE CORTADORA LA CON autopista PASO DE DERECHO APLASTAMIENTO DE RIESGO equipo del alejarse de antes elevadas partes lasBLOQUEEo IMPLEMENTO EL DESENGANCHAR AL CONECTAR DE SEGURIDADMPLEMENTO PTO DE ADAPTADOR UN UTILICE NOIMPLEMENTO DEL CONDUCCIÓN DE LÍNEA LA CONECTAR AL IMPLEMENTO OPERADOR DEL SEGURIDAD GENERAL OPERACIÓN DE SEGURIDADPTO DE VELOCIDAD SEGURIDAD DE SEÑALES MENOR LESIÓN UNA GENERALES PRÁCTICAS Y SEGURIDAD DE INSTRUCCIONESGRAVE MUY LESIÓN UNA O MUERTE SEGURIDAD DE SECCIÓN 1-1 Seguridad de SecciónPage NECESARIO SEA SEGÚN LUBRIQUE O AJUSTE Y VERIFIQUE ENTREGA LA DE ANTES SERVICIO AEM cortadora de Video OSHA DEL ENTRENAMIENTO DE REQUISITOS propietario/operador/distribuidor Al Inc Group Alamo OPERADOR DE MANUALGIRATORIA CORTADORA/TRITURADORA