Foreign Debris Hazards, Remove Foreign Material | Alamo 272, 284

Image 86

Alamo 272, 284, 260 manual Foreign Debris Hazards, Remove Foreign Material, Operation

Contents

ROTARY MOWER 260/272/284RHINO OPERATOR’S MANUAL Telephone To the Owner/Operator/DealerDealer Model Number OSHA TRAINING REQUIREMENTS one 1 AEM Mower Safety Practices Video Alamo Group Ag. Division will provide SAFETY ITEMS DEALER to CUSTOMER Pre-Delivery/ Operation InstructionsPRE-DELIVERY SERVICE CHECK AND ADJUST OR LUBRICATE AS REQUIRED ATTACHMENTS & INSTALLATIONPage ASSEMBLY SECTION Table of ContentsSAFETY SECTION INTRODUCTION SECTION MAINTENANCE SECTION BLADE REMOVAL BLADE CARRIER INSTALLATIONSEASONAL CLUTCH MAINTENANCE SLIP CLUTCHPage SAFETY SECTION Safety Section GENERAL SAFETY INSTRUCTIONS AND PRACTICES SAFETYSAFETY VISIBILITY CONDITIONS WHEN MOWING OPERATOR SAFETYGENERAL OPERATING SAFETY GROUND SPEED WHEN MOWING DO NOT USE PTO ADAPTER. Using a PTO adapter can cause CONNECTION OR DISCONNECTING IMPLEMENT SAFETYWHEN CONNECTING IMPLEMENT DRIVELINE ATTACHED WHEN UNHITCHING IMPLEMENT CRUSHING HAZARDSWHEN RAISING OR LOWERING IMPLEMENT TO AVOID CHILDREN FALLING OFF OR BEING CRUSHED BY EQUIPMENT INSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING THROWN OBJECTS HAZARDSSTOP MOWING IF PASSERSBY ARE WITHIN 300 FEET UNLESS HIGH GRASS and WEED AREA INSPECTION MOWER OPERATION THROWN OBJECTS HAZARDS CONTINUEDSTOP mowing when EXCESSIVE VIBRATION occurs AVOID MOWING in reverse ONLY mount or dismount when tractor and moving parts are stopped RUN OVER HAZARDSWHEN MOUNTING AND DISMOUNTING TRACTOR PTO SHIELDING PTO ENTANGLEMENT HAZARDSROTATING COMPONENTS CONTINUE to ROTATE after the PTO is shut off DO NOT USE PTO ADAPTER MOWER BLADE CONTACT HAZARDS HIGH PRESSURE OIL LEAK HAZARDS HIGH PRESSURE FLUID LEAKS CAN BE INVISIBLE ELECTRICAL & FIRE HAZARDS EQUIP Tractor with a FIRE EXTINGUISHER WHEN TOWING OR TRANSPORTING EQUIPMENT TRANSPORTING HAZARDSTOWED MOWERS - ENGAGE TRANSPORT LOCKS AND SAFETY CHAINS TRACTOR REQUIREMENTS FOR TOWING OR TRANSPORTING IMPLEMENTS SAFETY SHIELDS, GUARDS AND SAFETY DEVICES INSPECTION HAZARDS WITH MAINTENANCE OF IMPLEMENTBEFORE PERFORMING SERVICE, REPAIRS AND MAINTENANCE ON THE IMPLEMENT DISCONNECT IMPLEMENT driveline from tractor PTO SHAFT PARTS INFORMATION SEE YOUR RHINO DEALER Decal Location DESCRIPTION Decal Sheets Name 00781352 SAFETY Name 00781326 260 LOGOSTYPE Name 00781327 272 LOGOS Name 00781328 284 LOGOS Decal Description SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY This Act Seeks Federal Laws and RegulationsEmployer-Employee Operator Regulations DUTIES INTRODUCTION SECTION Introduction Section INTRODUCTION INTRODUCTION 130HP Equipment SpecificationsGearbox Rating 130HP Driveline Size Operating Noise Level/Sound Pressure Warranty informationKEY OPERATION POINTS 1020 S Sangamon Ave RHINO LIMITED WARRANTYRHINO Gibson City, ILPage ASSEMBLY SECTION Assembly Section DEALER SETUP INSTRUCTIONS ASSEMBLYASSEMBLY SHIELD ASSEMBLY All Models Asm-R-0408 TAIL WHEEL INSTALLATION Model 260TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only DUAL TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only A-FRAME INSTALLATION Quick Hitch Model A-FRAME INSTALLATION Model DRIVELINE ATTACHMENT AXLE ASSEMBLY TONGUE Pull Type HYDRAULIC OR MANUAL LIFT Model 284 Only WHEELS Model 284 Only Front Deflector Figure Asm-0045 Front and Rear Deflectors Standard EquipmentFront Rubber Fabric Deflectors Standard Equipment Rear Deflector - Figure Asm-R-0044 Rear Chain Guard - Figure Asm-R-0344 CHAIN GUARDS Optional Equipment - All ModelsFront Chain Guards Figure Asm-R-0343 NOTE 260 and 272 units use a Cat I Kit and 284 Units use a Cat II Kit CHECK CHAINS Extra EquipmentNOTE Figure ASM-0038 shows optional spring shock installation OFFSET ADAPTER HITCH EXTRA EQUIPMENT Page OPERATION SECTION Operation Section RHINO 260/272/284 ROTARY MOWER OPERATION INSTRUCTIONS OPERATIONOPERATION 1. OPERATOR REQUIREMENTS PERSONAL PROTECTIVE EQUIPMENT PPE 2.1 ROPS and Seat Belt 2. TRACTOR REQUIREMENTSTractor Requirements and Capabilities 2.2 Tractor Safety Devices 2.3 3-Point Hitch 2.5 Drawbar-Pull Type Mower 2.4 Front End Weight2.6 Power Take Off PTO 3. GETTING ON AND OFF THE TRACTOR 3.1 Boarding the Tractor Essential Tractor Controls 4. STARTING THE TRACTOR3.2 Dismounting the Tractor Before starting the tractor ensure the following 5. CONNECTING THE MOWER TO THE TRACTOR 5.1 Connecting Mower-Lift Type 5.2 3-Point Quick Hitch 5.3 Connecting Mower - Lift Type Quick Hitch 5.4 Safety Tow Chain 6. SETTING THE MOWER 6.1 Setting Mower Height- Lift Type - Standard or Quick Hitch NOTE Install optional check chains when there is a problem with the hydraulic 3-Point lift maintaining a set height or when a constant pre-adjusted cut height is required. See Check Chains in the Assembly Section for this accessory 6.2 Connecting the Mower-Pull Type 6.3 Setting Mowing Height-Pull Type Lower Horse Power - Better Fuel Efficiency 6.4 Setting Deck Pitch7. DRIVELINE ATTACHMENT Increase Mulching 7.1 Driveline Length Check “Bottoming Out” Check Procedure Shorten the driveline profiles as follows 8. PRE-OPERATION INSPECTION AND SERVICEEngagement Check Procedure OPERATION 8.1 Tractor Pre-Operation Inspection/Service 8.2 Mower Pre-Operation Inspection/Service OPERATION OPERATION OPERATION 8.3 Cutting Component Inspection OPS-U-0031 OPERATION OPERATION OPERATION 8.4 Blade Bolt Inspection Tractor ID# Tractor PRE-OPERATION InspectionDO NOT OPERATE an UNSAFE TRACTOR or MOWER Make Rotary Mower PRE-OPERATION Inspection 9. DRIVING THE TRACTOR AND IMPLEMENT 9.2 Brake and Differential Lock Setting 9.1 Starting the Tractor 9.3 Raising the Mower 9.4 Driving the Tractor and Mower 9.5 Crossing Ditches and Steep Inclines 10. OPERATING THE TRACTOR AND IMPLEMENT OPS-R-0022 Remove Foreign Material Raise Mower over solid objects 10.2 Bystanders/Passersby Precautions10.1 Foreign Debris Hazards 10.3 Engaging the Power Take Off PTO STOP MOWING IF PASSERSBY ARE WITHIN 300 Feet UNLESS 10.4 PTO RPM and Ground Speed 10.5 Operating the Mower SGM-08 OPERATION STOP MOWING IF PASSERSBY IS WITHIN 300 FEET UNLESS 4. RAISE CUTTING HEIGHT to 6 INCHES minimumINSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING 11. DISCONNECTING THE MOWER FROM THE TRACTOR 10.6 Shutting Down the Implement OPERATION 12. MOWER STORAGE 13. TRANSPORTING THE TRACTOR AND IMPLEMENT 13.1 Transporting on Public Roadways OPERATION 13.2 Hauling the Tractor and Implement Possible Cause 14. TROUBLE SHOOTING GUIDEProblem Remedy OPERATION OPERATIONPage MAINTENANCE SECTION Maintenance Section MAINTENANCE MAINTENANCE Lubrication MAINTENANCE MAINTENANCE MAINTENANCE GEARBOX Model TAIL WHEEL ASSEMBLYGEARBOX Model 260 DRIVELINE LUBRICATION LIFT TYPE DRIVELINE & PULL JACKSHAFT SHIELDS CV TYPE DRIVELINE MAIN CV DRIVELINE SAFETY SHIELD NOTE Replace Blades in pairs after no more than 1/2” notch wear BLADE SERVICINGNOTE Correct Blade Rotation is counter-clockwise viewed from the top BLADE SHARPENING BLADE CARRIER REMOVAL BLADE CARRIER INSPECTION BLADE CARRIER INSTALLATION BLADE REMOVAL SLIP CLUTCH SEASONAL CLUTCH MAINTENANCE STORAGE PROPER TORQUE FOR FASTENERS PARTES DE INFORMACIÓN SEGURIDADSEGURIDAD RHINO DISTRIBUIDOR SU A CONTACTE IMPLEMENTO DEL MANTENIMIENTO DE SECCIÓN IMPLEMENTO DEL MANTENIMIENTO EL CON RIESGOSCUCHILLAS DE INSPECCIÓN APROPIADO MANTENIMIENTO O REPARACIÓN SERVICIO, UN EQUIPO EL TRANSPORTAR O REMOLCAR AL TRANSPORTE EN RIESGOStractor del ADVERTENCIA DE BALIZAS LAS ENCIENDA IRREGULAR SERVICIOS DE Y GAS DE LÍNEAS ELÉCTRICOS, CABLES DE CERCA TRABAJAR FUEGO DE Y ELÉCRTICOS RIESGOSMATAFUEGOS CON EQUIPADO estar debe tractor El AL ELÉCTRICO CONTACTO POR MUERTE LA O GRAVES LESIONES EVITAR PARA VISIBLES SER NO PUEDEN PRESIÓN ALTA DE LÍQUIDO DE FILTRACIONES LAS CORTADORA DE CUCHILLAS LAS A CONTACTO DEL RIESGOPRESIÓN ALTA DE HIDRÁULICO ACEITE DE FILTRACION DE RIESGO PRESIÓN ALTA DE HIDRÁULICO ACEITE PTO LA DE PROTECCIÓN PTO EL POR ENREDO DE RIESGOPTO DE ADAPTADOR UN UTILICE NO PTO la apagada vez una ROTANDO SIGUEN GIRATORIOS ELEMENTOS LOS EQUIPO DEL ATROPELLO DE RIESGOTRACTOR DEL BAJAR Y SUBIR AL tractor del MOTOR EL Y PTO EL DETENGA Continuado LANZADOS OBJECTOS DE RIESGOdañadas o dobladas CUCHILLAS las o dañada parte toda REEMPLACE reversa en CORTADORA LA OPERAR EVITE mínimo, como PULGADAS 6 CM 15 a CORTE DE ALTURA LA ELEVE LANZADOS OBJECTOS DE RIESGOARROJADOS CORTADORA LA CON autopista PASO DE DERECHO BLOQUEEo APLASTAMIENTO DE RIESGOequipo del alejarse de antes elevadas partes las IMPLEMENTO EL DESENGANCHAR AL IMPLEMENTO DEL CONDUCCIÓN DE LÍNEA LA CONECTAR AL CONECTAR DE SEGURIDADMPLEMENTOPTO DE ADAPTADOR UN UTILICE NO IMPLEMENTO PTO DE VELOCIDAD OPERADOR DEL SEGURIDADGENERAL OPERACIÓN DE SEGURIDAD SEGURIDAD DE SEÑALES GRAVE MUY LESIÓN UNA O MUERTE GENERALES PRÁCTICAS Y SEGURIDAD DE INSTRUCCIONESMENOR LESIÓN UNA SEGURIDAD DE SECCIÓN 1-1 Seguridad de SecciónPage NECESARIO SEA SEGÚN LUBRIQUE O AJUSTE Y VERIFIQUE ENTREGA LA DE ANTES SERVICIO AEM cortadora de Video OSHA DEL ENTRENAMIENTO DE REQUISITOS propietario/operador/distribuidor Al GIRATORIA CORTADORA/TRITURADORA OPERADOR DE MANUALInc Group Alamo