Slip Clutch, Maintenance | Alamo 284, 260, 272 guide

Image 114

Alamo 284, 260, 272 manual Slip Clutch, Maintenance

Contents

ROTARY MOWER 260/272/284RHINO OPERATOR’S MANUAL Telephone To the Owner/Operator/DealerDealer Model Number OSHA TRAINING REQUIREMENTS one 1 AEM Mower Safety Practices Video Alamo Group Ag. Division will provide SAFETY ITEMS DEALER to CUSTOMER Pre-Delivery/ Operation InstructionsPRE-DELIVERY SERVICE CHECK AND ADJUST OR LUBRICATE AS REQUIRED ATTACHMENTS & INSTALLATIONPage ASSEMBLY SECTION Table of ContentsSAFETY SECTION INTRODUCTION SECTION MAINTENANCE SECTION BLADE REMOVAL BLADE CARRIER INSTALLATIONSEASONAL CLUTCH MAINTENANCE SLIP CLUTCHPage SAFETY SECTION Safety Section SAFETY SAFETYGENERAL SAFETY INSTRUCTIONS AND PRACTICES VISIBILITY CONDITIONS WHEN MOWING OPERATOR SAFETYGENERAL OPERATING SAFETY GROUND SPEED WHEN MOWING DO NOT USE PTO ADAPTER. Using a PTO adapter can cause CONNECTION OR DISCONNECTING IMPLEMENT SAFETYWHEN CONNECTING IMPLEMENT DRIVELINE ATTACHED WHEN UNHITCHING IMPLEMENT CRUSHING HAZARDSWHEN RAISING OR LOWERING IMPLEMENT TO AVOID CHILDREN FALLING OFF OR BEING CRUSHED BY EQUIPMENT INSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING THROWN OBJECTS HAZARDSSTOP MOWING IF PASSERSBY ARE WITHIN 300 FEET UNLESS HIGH GRASS and WEED AREA INSPECTION MOWER OPERATION THROWN OBJECTS HAZARDS CONTINUEDSTOP mowing when EXCESSIVE VIBRATION occurs AVOID MOWING in reverse RUN OVER HAZARDS WHEN MOUNTING AND DISMOUNTING TRACTORONLY mount or dismount when tractor and moving parts are stopped PTO SHIELDING PTO ENTANGLEMENT HAZARDSROTATING COMPONENTS CONTINUE to ROTATE after the PTO is shut off DO NOT USE PTO ADAPTER MOWER BLADE CONTACT HAZARDS HIGH PRESSURE OIL LEAK HAZARDS HIGH PRESSURE FLUID LEAKS CAN BE INVISIBLE ELECTRICAL & FIRE HAZARDS EQUIP Tractor with a FIRE EXTINGUISHER WHEN TOWING OR TRANSPORTING EQUIPMENT TRANSPORTING HAZARDSTOWED MOWERS - ENGAGE TRANSPORT LOCKS AND SAFETY CHAINS TRACTOR REQUIREMENTS FOR TOWING OR TRANSPORTING IMPLEMENTS SAFETY SHIELDS, GUARDS AND SAFETY DEVICES INSPECTION HAZARDS WITH MAINTENANCE OF IMPLEMENTBEFORE PERFORMING SERVICE, REPAIRS AND MAINTENANCE ON THE IMPLEMENT DISCONNECT IMPLEMENT driveline from tractor PTO SHAFT PARTS INFORMATION SEE YOUR RHINO DEALER Decal Location DESCRIPTION Decal Sheets Name 00781352 SAFETY Name 00781326 260 LOGOSTYPE Name 00781327 272 LOGOS Name 00781328 284 LOGOS Decal Description SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY This Act Seeks Federal Laws and RegulationsEmployer-Employee Operator Regulations DUTIES INTRODUCTION SECTION Introduction Section INTRODUCTION INTRODUCTION 130HP Equipment SpecificationsGearbox Rating 130HP Driveline Size Warranty information KEY OPERATION POINTSOperating Noise Level/Sound Pressure 1020 S Sangamon Ave RHINO LIMITED WARRANTYRHINO Gibson City, ILPage ASSEMBLY SECTION Assembly Section DEALER SETUP INSTRUCTIONS ASSEMBLYASSEMBLY SHIELD ASSEMBLY All Models TAIL WHEEL INSTALLATION Model 260 TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 OnlyAsm-R-0408 DUAL TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only A-FRAME INSTALLATION Quick Hitch Model A-FRAME INSTALLATION Model DRIVELINE ATTACHMENT AXLE ASSEMBLY TONGUE Pull Type HYDRAULIC OR MANUAL LIFT Model 284 Only WHEELS Model 284 Only Front Deflector Figure Asm-0045 Front and Rear Deflectors Standard EquipmentFront Rubber Fabric Deflectors Standard Equipment Rear Deflector - Figure Asm-R-0044 CHAIN GUARDS Optional Equipment - All Models Front Chain Guards Figure Asm-R-0343Rear Chain Guard - Figure Asm-R-0344 CHECK CHAINS Extra Equipment NOTE Figure ASM-0038 shows optional spring shock installationNOTE 260 and 272 units use a Cat I Kit and 284 Units use a Cat II Kit OFFSET ADAPTER HITCH EXTRA EQUIPMENT Page OPERATION SECTION Operation Section OPERATION OPERATIONRHINO 260/272/284 ROTARY MOWER OPERATION INSTRUCTIONS 1. OPERATOR REQUIREMENTS PERSONAL PROTECTIVE EQUIPMENT PPE 2. TRACTOR REQUIREMENTS Tractor Requirements and Capabilities2.1 ROPS and Seat Belt 2.2 Tractor Safety Devices 2.3 3-Point Hitch 2.4 Front End Weight 2.6 Power Take Off PTO2.5 Drawbar-Pull Type Mower 3. GETTING ON AND OFF THE TRACTOR 3.1 Boarding the Tractor Essential Tractor Controls 4. STARTING THE TRACTOR3.2 Dismounting the Tractor Before starting the tractor ensure the following 5. CONNECTING THE MOWER TO THE TRACTOR 5.1 Connecting Mower-Lift Type 5.2 3-Point Quick Hitch 5.3 Connecting Mower - Lift Type Quick Hitch 5.4 Safety Tow Chain 6. SETTING THE MOWER 6.1 Setting Mower Height- Lift Type - Standard or Quick Hitch NOTE Install optional check chains when there is a problem with the hydraulic 3-Point lift maintaining a set height or when a constant pre-adjusted cut height is required. See Check Chains in the Assembly Section for this accessory 6.2 Connecting the Mower-Pull Type 6.3 Setting Mowing Height-Pull Type Lower Horse Power - Better Fuel Efficiency 6.4 Setting Deck Pitch7. DRIVELINE ATTACHMENT Increase Mulching 7.1 Driveline Length Check “Bottoming Out” Check Procedure 8. PRE-OPERATION INSPECTION AND SERVICE Engagement Check ProcedureShorten the driveline profiles as follows OPERATION 8.1 Tractor Pre-Operation Inspection/Service 8.2 Mower Pre-Operation Inspection/Service OPERATION OPERATION OPERATION 8.3 Cutting Component Inspection OPS-U-0031 OPERATION OPERATION OPERATION 8.4 Blade Bolt Inspection Tractor ID# Tractor PRE-OPERATION InspectionDO NOT OPERATE an UNSAFE TRACTOR or MOWER Make Rotary Mower PRE-OPERATION Inspection 9. DRIVING THE TRACTOR AND IMPLEMENT 9.2 Brake and Differential Lock Setting 9.1 Starting the Tractor 9.3 Raising the Mower 9.4 Driving the Tractor and Mower 9.5 Crossing Ditches and Steep Inclines 10. OPERATING THE TRACTOR AND IMPLEMENT OPS-R-0022 Raise Mower over solid objects 10.2 Bystanders/Passersby Precautions 10.1 Foreign Debris HazardsRemove Foreign Material 10.3 Engaging the Power Take Off PTO STOP MOWING IF PASSERSBY ARE WITHIN 300 Feet UNLESS 10.4 PTO RPM and Ground Speed 10.5 Operating the Mower SGM-08 OPERATION 4. RAISE CUTTING HEIGHT to 6 INCHES minimum INSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWINGSTOP MOWING IF PASSERSBY IS WITHIN 300 FEET UNLESS 11. DISCONNECTING THE MOWER FROM THE TRACTOR 10.6 Shutting Down the Implement OPERATION 12. MOWER STORAGE 13. TRANSPORTING THE TRACTOR AND IMPLEMENT 13.1 Transporting on Public Roadways OPERATION 13.2 Hauling the Tractor and Implement Possible Cause 14. TROUBLE SHOOTING GUIDEProblem Remedy OPERATION OPERATIONPage MAINTENANCE SECTION Maintenance Section MAINTENANCE MAINTENANCE Lubrication MAINTENANCE MAINTENANCE MAINTENANCE TAIL WHEEL ASSEMBLY GEARBOX Model 260GEARBOX Model DRIVELINE LUBRICATION LIFT TYPE DRIVELINE & PULL JACKSHAFT SHIELDS CV TYPE DRIVELINE MAIN CV DRIVELINE SAFETY SHIELD BLADE SERVICING NOTE Correct Blade Rotation is counter-clockwise viewed from the topNOTE Replace Blades in pairs after no more than 1/2” notch wear BLADE SHARPENING BLADE CARRIER REMOVAL BLADE CARRIER INSPECTION BLADE CARRIER INSTALLATION BLADE REMOVAL SLIP CLUTCH SEASONAL CLUTCH MAINTENANCE STORAGE PROPER TORQUE FOR FASTENERS PARTES DE INFORMACIÓN SEGURIDADSEGURIDAD RHINO DISTRIBUIDOR SU A CONTACTE IMPLEMENTO DEL MANTENIMIENTO DE SECCIÓN IMPLEMENTO DEL MANTENIMIENTO EL CON RIESGOSCUCHILLAS DE INSPECCIÓN APROPIADO MANTENIMIENTO O REPARACIÓN SERVICIO, UN EQUIPO EL TRANSPORTAR O REMOLCAR AL TRANSPORTE EN RIESGOStractor del ADVERTENCIA DE BALIZAS LAS ENCIENDA IRREGULAR SERVICIOS DE Y GAS DE LÍNEAS ELÉCTRICOS, CABLES DE CERCA TRABAJAR FUEGO DE Y ELÉCRTICOS RIESGOSMATAFUEGOS CON EQUIPADO estar debe tractor El AL ELÉCTRICO CONTACTO POR MUERTE LA O GRAVES LESIONES EVITAR PARA VISIBLES SER NO PUEDEN PRESIÓN ALTA DE LÍQUIDO DE FILTRACIONES LAS CORTADORA DE CUCHILLAS LAS A CONTACTO DEL RIESGOPRESIÓN ALTA DE HIDRÁULICO ACEITE DE FILTRACION DE RIESGO PRESIÓN ALTA DE HIDRÁULICO ACEITE PTO LA DE PROTECCIÓN PTO EL POR ENREDO DE RIESGOPTO DE ADAPTADOR UN UTILICE NO PTO la apagada vez una ROTANDO SIGUEN GIRATORIOS ELEMENTOS LOS ATROPELLO DE RIESGO TRACTOR DEL BAJAR Y SUBIR ALEQUIPO DEL tractor del MOTOR EL Y PTO EL DETENGA Continuado LANZADOS OBJECTOS DE RIESGOdañadas o dobladas CUCHILLAS las o dañada parte toda REEMPLACE reversa en CORTADORA LA OPERAR EVITE mínimo, como PULGADAS 6 CM 15 a CORTE DE ALTURA LA ELEVE LANZADOS OBJECTOS DE RIESGOARROJADOS CORTADORA LA CON autopista PASO DE DERECHO BLOQUEEo APLASTAMIENTO DE RIESGOequipo del alejarse de antes elevadas partes las IMPLEMENTO EL DESENGANCHAR AL IMPLEMENTO DEL CONDUCCIÓN DE LÍNEA LA CONECTAR AL CONECTAR DE SEGURIDADMPLEMENTOPTO DE ADAPTADOR UN UTILICE NO IMPLEMENTO PTO DE VELOCIDAD OPERADOR DEL SEGURIDADGENERAL OPERACIÓN DE SEGURIDAD SEGURIDAD DE SEÑALES GENERALES PRÁCTICAS Y SEGURIDAD DE INSTRUCCIONES MENOR LESIÓN UNAGRAVE MUY LESIÓN UNA O MUERTE SEGURIDAD DE SECCIÓN 1-1 Seguridad de SecciónPage NECESARIO SEA SEGÚN LUBRIQUE O AJUSTE Y VERIFIQUE ENTREGA LA DE ANTES SERVICIO AEM cortadora de Video OSHA DEL ENTRENAMIENTO DE REQUISITOS propietario/operador/distribuidor Al OPERADOR DE MANUAL Inc Group AlamoGIRATORIA CORTADORA/TRITURADORA