Maintenance Section | Alamo 272, 284, 260 specs

Image 8

Alamo 272, 284, 260 manual Maintenance Section

Contents

260/272/284 RHINOROTARY MOWER OPERATOR’S MANUAL To the Owner/Operator/Dealer DealerTelephone Model Number OSHA TRAINING REQUIREMENTS one 1 AEM Mower Safety Practices Video Alamo Group Ag. Division will provide DEALER to CUSTOMER Pre-Delivery/ Operation Instructions PRE-DELIVERY SERVICE CHECK AND ADJUST OR LUBRICATE AS REQUIREDSAFETY ITEMS ATTACHMENTS & INSTALLATIONPage Table of Contents SAFETY SECTIONASSEMBLY SECTION INTRODUCTION SECTION MAINTENANCE SECTION BLADE CARRIER INSTALLATION SEASONAL CLUTCH MAINTENANCEBLADE REMOVAL SLIP CLUTCHPage SAFETY SECTION Safety Section GENERAL SAFETY INSTRUCTIONS AND PRACTICES SAFETYSAFETY OPERATOR SAFETY GENERAL OPERATING SAFETYVISIBILITY CONDITIONS WHEN MOWING GROUND SPEED WHEN MOWING CONNECTION OR DISCONNECTING IMPLEMENT SAFETY WHEN CONNECTING IMPLEMENT DRIVELINEDO NOT USE PTO ADAPTER. Using a PTO adapter can cause ATTACHED CRUSHING HAZARDS WHEN RAISING OR LOWERING IMPLEMENTWHEN UNHITCHING IMPLEMENT TO AVOID CHILDREN FALLING OFF OR BEING CRUSHED BY EQUIPMENT THROWN OBJECTS HAZARDS STOP MOWING IF PASSERSBY ARE WITHIN 300 FEET UNLESSINSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING HIGH GRASS and WEED AREA INSPECTION THROWN OBJECTS HAZARDS CONTINUED STOP mowing when EXCESSIVE VIBRATION occursMOWER OPERATION AVOID MOWING in reverse ONLY mount or dismount when tractor and moving parts are stopped RUN OVER HAZARDSWHEN MOUNTING AND DISMOUNTING TRACTOR PTO ENTANGLEMENT HAZARDS ROTATING COMPONENTS CONTINUE to ROTATE after the PTO is shut offPTO SHIELDING DO NOT USE PTO ADAPTER MOWER BLADE CONTACT HAZARDS HIGH PRESSURE OIL LEAK HAZARDS HIGH PRESSURE FLUID LEAKS CAN BE INVISIBLE ELECTRICAL & FIRE HAZARDS EQUIP Tractor with a FIRE EXTINGUISHER TRANSPORTING HAZARDS TOWED MOWERS - ENGAGE TRANSPORT LOCKS AND SAFETY CHAINSWHEN TOWING OR TRANSPORTING EQUIPMENT TRACTOR REQUIREMENTS FOR TOWING OR TRANSPORTING IMPLEMENTS HAZARDS WITH MAINTENANCE OF IMPLEMENT BEFORE PERFORMING SERVICE, REPAIRS AND MAINTENANCE ON THE IMPLEMENTSAFETY SHIELDS, GUARDS AND SAFETY DEVICES INSPECTION DISCONNECT IMPLEMENT driveline from tractor PTO SHAFT PARTS INFORMATION SEE YOUR RHINO DEALER Decal Location Decal Sheets Name 00781352 SAFETY Name 00781326 260 LOGOS TYPEDESCRIPTION Name 00781327 272 LOGOS Name 00781328 284 LOGOS Decal Description SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY SAFETY Federal Laws and Regulations Employer-Employee Operator RegulationsThis Act Seeks DUTIES INTRODUCTION SECTION Introduction Section INTRODUCTION INTRODUCTION Equipment Specifications Gearbox Rating 130HP130HP Driveline Size Operating Noise Level/Sound Pressure Warranty informationKEY OPERATION POINTS RHINO LIMITED WARRANTY RHINO1020 S Sangamon Ave Gibson City, ILPage ASSEMBLY SECTION Assembly Section ASSEMBLY ASSEMBLYDEALER SETUP INSTRUCTIONS SHIELD ASSEMBLY All Models Asm-R-0408 TAIL WHEEL INSTALLATION Model 260TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only DUAL TAIL WHEEL INSTALLATION - LIFT TYPE Model 284 Only A-FRAME INSTALLATION Quick Hitch Model A-FRAME INSTALLATION Model DRIVELINE ATTACHMENT AXLE ASSEMBLY TONGUE Pull Type HYDRAULIC OR MANUAL LIFT Model 284 Only WHEELS Model 284 Only Front and Rear Deflectors Standard Equipment Front Rubber Fabric Deflectors Standard EquipmentFront Deflector Figure Asm-0045 Rear Deflector - Figure Asm-R-0044 Rear Chain Guard - Figure Asm-R-0344 CHAIN GUARDS Optional Equipment - All ModelsFront Chain Guards Figure Asm-R-0343 NOTE 260 and 272 units use a Cat I Kit and 284 Units use a Cat II Kit CHECK CHAINS Extra EquipmentNOTE Figure ASM-0038 shows optional spring shock installation OFFSET ADAPTER HITCH EXTRA EQUIPMENT Page OPERATION SECTION Operation Section RHINO 260/272/284 ROTARY MOWER OPERATION INSTRUCTIONS OPERATIONOPERATION 1. OPERATOR REQUIREMENTS PERSONAL PROTECTIVE EQUIPMENT PPE 2.1 ROPS and Seat Belt 2. TRACTOR REQUIREMENTSTractor Requirements and Capabilities 2.2 Tractor Safety Devices 2.3 3-Point Hitch 2.5 Drawbar-Pull Type Mower 2.4 Front End Weight2.6 Power Take Off PTO 3. GETTING ON AND OFF THE TRACTOR 3.1 Boarding the Tractor 4. STARTING THE TRACTOR 3.2 Dismounting the TractorEssential Tractor Controls Before starting the tractor ensure the following 5. CONNECTING THE MOWER TO THE TRACTOR 5.1 Connecting Mower-Lift Type 5.2 3-Point Quick Hitch 5.3 Connecting Mower - Lift Type Quick Hitch 5.4 Safety Tow Chain 6. SETTING THE MOWER 6.1 Setting Mower Height- Lift Type - Standard or Quick Hitch NOTE Install optional check chains when there is a problem with the hydraulic 3-Point lift maintaining a set height or when a constant pre-adjusted cut height is required. See Check Chains in the Assembly Section for this accessory 6.2 Connecting the Mower-Pull Type 6.3 Setting Mowing Height-Pull Type 6.4 Setting Deck Pitch 7. DRIVELINE ATTACHMENTLower Horse Power - Better Fuel Efficiency Increase Mulching 7.1 Driveline Length Check “Bottoming Out” Check Procedure Shorten the driveline profiles as follows 8. PRE-OPERATION INSPECTION AND SERVICEEngagement Check Procedure OPERATION 8.1 Tractor Pre-Operation Inspection/Service 8.2 Mower Pre-Operation Inspection/Service OPERATION OPERATION OPERATION 8.3 Cutting Component Inspection OPS-U-0031 OPERATION OPERATION OPERATION 8.4 Blade Bolt Inspection Tractor PRE-OPERATION Inspection DO NOT OPERATE an UNSAFE TRACTOR or MOWERTractor ID# Make Rotary Mower PRE-OPERATION Inspection 9. DRIVING THE TRACTOR AND IMPLEMENT 9.2 Brake and Differential Lock Setting 9.1 Starting the Tractor 9.3 Raising the Mower 9.4 Driving the Tractor and Mower 9.5 Crossing Ditches and Steep Inclines 10. OPERATING THE TRACTOR AND IMPLEMENT OPS-R-0022 Remove Foreign Material Raise Mower over solid objects 10.2 Bystanders/Passersby Precautions10.1 Foreign Debris Hazards 10.3 Engaging the Power Take Off PTO STOP MOWING IF PASSERSBY ARE WITHIN 300 Feet UNLESS 10.4 PTO RPM and Ground Speed 10.5 Operating the Mower SGM-08 OPERATION STOP MOWING IF PASSERSBY IS WITHIN 300 FEET UNLESS 4. RAISE CUTTING HEIGHT to 6 INCHES minimumINSPECT AREA FOR POTENTIAL THROWN OBJECTS BEFORE MOWING 11. DISCONNECTING THE MOWER FROM THE TRACTOR 10.6 Shutting Down the Implement OPERATION 12. MOWER STORAGE 13. TRANSPORTING THE TRACTOR AND IMPLEMENT 13.1 Transporting on Public Roadways OPERATION 13.2 Hauling the Tractor and Implement 14. TROUBLE SHOOTING GUIDE ProblemPossible Cause Remedy OPERATION OPERATIONPage MAINTENANCE SECTION Maintenance Section MAINTENANCE MAINTENANCE Lubrication MAINTENANCE MAINTENANCE MAINTENANCE GEARBOX Model TAIL WHEEL ASSEMBLYGEARBOX Model 260 DRIVELINE LUBRICATION LIFT TYPE DRIVELINE & PULL JACKSHAFT SHIELDS CV TYPE DRIVELINE MAIN CV DRIVELINE SAFETY SHIELD NOTE Replace Blades in pairs after no more than 1/2” notch wear BLADE SERVICINGNOTE Correct Blade Rotation is counter-clockwise viewed from the top BLADE SHARPENING BLADE CARRIER REMOVAL BLADE CARRIER INSPECTION BLADE CARRIER INSTALLATION BLADE REMOVAL SLIP CLUTCH SEASONAL CLUTCH MAINTENANCE STORAGE PROPER TORQUE FOR FASTENERS SEGURIDAD SEGURIDADPARTES DE INFORMACIÓN RHINO DISTRIBUIDOR SU A CONTACTE IMPLEMENTO DEL MANTENIMIENTO EL CON RIESGOS CUCHILLAS DE INSPECCIÓNIMPLEMENTO DEL MANTENIMIENTO DE SECCIÓN APROPIADO MANTENIMIENTO O REPARACIÓN SERVICIO, UN TRANSPORTE EN RIESGOS tractor del ADVERTENCIA DE BALIZAS LAS ENCIENDAEQUIPO EL TRANSPORTAR O REMOLCAR AL IRREGULAR FUEGO DE Y ELÉCRTICOS RIESGOS MATAFUEGOS CON EQUIPADO estar debe tractor ElSERVICIOS DE Y GAS DE LÍNEAS ELÉCTRICOS, CABLES DE CERCA TRABAJAR AL ELÉCTRICO CONTACTO POR MUERTE LA O GRAVES LESIONES EVITAR PARA CORTADORA DE CUCHILLAS LAS A CONTACTO DEL RIESGO PRESIÓN ALTA DE HIDRÁULICO ACEITE DE FILTRACION DE RIESGOVISIBLES SER NO PUEDEN PRESIÓN ALTA DE LÍQUIDO DE FILTRACIONES LAS PRESIÓN ALTA DE HIDRÁULICO ACEITE PTO EL POR ENREDO DE RIESGO PTO DE ADAPTADOR UN UTILICE NOPTO LA DE PROTECCIÓN PTO la apagada vez una ROTANDO SIGUEN GIRATORIOS ELEMENTOS LOS EQUIPO DEL ATROPELLO DE RIESGOTRACTOR DEL BAJAR Y SUBIR AL Continuado LANZADOS OBJECTOS DE RIESGO dañadas o dobladas CUCHILLAS las o dañada parte toda REEMPLACEtractor del MOTOR EL Y PTO EL DETENGA reversa en CORTADORA LA OPERAR EVITE LANZADOS OBJECTOS DE RIESGO ARROJADOSmínimo, como PULGADAS 6 CM 15 a CORTE DE ALTURA LA ELEVE CORTADORA LA CON autopista PASO DE DERECHO APLASTAMIENTO DE RIESGO equipo del alejarse de antes elevadas partes lasBLOQUEEo IMPLEMENTO EL DESENGANCHAR AL CONECTAR DE SEGURIDADMPLEMENTO PTO DE ADAPTADOR UN UTILICE NOIMPLEMENTO DEL CONDUCCIÓN DE LÍNEA LA CONECTAR AL IMPLEMENTO OPERADOR DEL SEGURIDAD GENERAL OPERACIÓN DE SEGURIDADPTO DE VELOCIDAD SEGURIDAD DE SEÑALES GRAVE MUY LESIÓN UNA O MUERTE GENERALES PRÁCTICAS Y SEGURIDAD DE INSTRUCCIONESMENOR LESIÓN UNA SEGURIDAD DE SECCIÓN 1-1 Seguridad de SecciónPage NECESARIO SEA SEGÚN LUBRIQUE O AJUSTE Y VERIFIQUE ENTREGA LA DE ANTES SERVICIO AEM cortadora de Video OSHA DEL ENTRENAMIENTO DE REQUISITOS propietario/operador/distribuidor Al GIRATORIA CORTADORA/TRITURADORA OPERADOR DE MANUALInc Group Alamo