INSTALLATION
WATER SUPPLY & INSTALLATION
Flush the water line at the installation site.
Install water intake filters (provided) [see Figure 1] before connecting the oven to the water supply.
Backflow Prevention — The equipment must be installed with adequate backflow protection to comply with applicable federal, state, and local codes.
PiPe sealing TaPe (Teflon®) musT be used aT all ConneCTion PoinTs. The use of a pipe
sealing compound is not recommended.
TWO (2) COLD WATER INLETS - DRINKING QUALITY
ONE (1) TREATED WATER INLET: | 3/4" NPT* | * Can manifold off of |
ONE (1) UNTREATED WATER INLET: 3/4" NPT* | one 3/4" line. | |
LINE PRESSURE: | 30 to 90 psi | 2.8 to 6.2 bar |
WATER DRAIN:
| ONE SUggESTEd |
| Install water | |
| METHOd OF INSTALLATION |
| intake filters | |
Incoming cold | Water Filter |
|
| |
water connection |
|
| ||
|
|
| ||
|
|
| Figure 1 | |
T connection |
|
|
| |
| Cold water | Treated cold water | ||
| line to filter | to backflow preventer | ||
| or treatment | to treated connection | ||
Cold water line | system | on oven |
| |
to untreated |
|
|
| |
oven connection |
|
|
| |
| CombiGuard™ |
| NOTE: | |
|
| |||
|
|
| boTh TReaTed and unTReaTed | |
| waTeR ConneCTions musT | |||
| be ConneCTed foR PRoPeR | |||
filtration system for Combitherm®. The |
| |||
CombiGuard™ 10 & 20 |
| oPeRaTion of The oven. | ||
| boTh ConneCTions Can be | |||
filtration system filters dirt, sediment, and other |
| |||
| TReaTed waTeR, buT should | |||
debris as small as 1/2 micron. This system also significantly reduces |
| |||
| neveR be ConneCTed To onlY | |||
chlorine content to protect against corrosive chorine compounds. |
| |||
| unTReaTed waTeR. | |||
CombiGuard improves equipment efficiency, reduces service requirements | ||||
| ||||
and extends the life of the Combi oven. After installation, confirm that |
| unions oR fleXible lines | ||
water quality standards specified in this manual are being met. Filtration |
| should be used To allow foR | ||
systems include one filter cartridge. Additional cartridges can be purchased | oven movemenT when being | |||
separately. Refer to an earlier page for additional ordering information. |
| seRviCed oR Cleaning | ||
The CombiGuard™ BWS Blended Water System utilizes reverse osmosis to | is needed. | |||
| ||||
remove more than 97% of the total dissolved solids from water which can be |
| |||
precisely blended with filtered and treated water. |
|
|
COMBITOUCH® ESG SERIES • GAS INSTALLATION MANUAL •