EURO • Printed in England • GB • F016 L69 838 • CLUB/ROYALE • OSW 08/01
CLUB/ROYALE - Buch Seite 5 Dienstag, 7. August 2001 2:41 14
Battery |
| Accessories |
|
|
|
If battery is removed, do not operate engine without insulating POS+ (red) battery cable ter- minal with electrical tape, or sparking from bat- tery cables can result.
Charging:
When charging the battery disconnect the battery ter- minals. The battery fitted to the mower is 14 Ah rated, charge the battery as per the instruction for the charger you are using (not supplied).
autosteer seat + pack | Royale 20 | F016 800104 |
autosteer seat + pack | Royale 24 | F016 800105 |
autosteer seat + pack | Royale 30 | F016 800106 |
side wheel kit | Royale 20 | F016 L80928 |
side wheel kit | Royale 24 | F016 L80929 |
side wheel kit | Royale 30 | F016 L80930 |
wheel and stand kit | Club 20 | F016 L80019 |
1 litre of SAE 30 API SF Oil | F016 S10258 | |
|
|
|
|
| Lublication |
| Winter Storage/Storage over 30 day | |
|
|
|
|
|
|
|
| |
|
|
|
|
|
| |||
| C |
|
| D |
| Regular maintenace at the recommended service in- | ||
The need for lubrication is minimal as moving parts | tervals, replacing worn or damaged parts as necessary | |||||||
and having the mower serviced by an ATCO Ap- | ||||||||
run on sealed bearings. The few lublication points 29 | ||||||||
proved Service Agent before winter storage will max- | ||||||||
are and require lublication a few drops of engine oil | ||||||||
imize the life and reliability of the mower. Observe | ||||||||
every 2 months. | ||||||||
the following before storage: | ||||||||
|
|
|
|
|
|
| ||
|
|
|
|
|
|
| Clean the mower down thoroughly. Remove any | |
|
|
|
|
| Engine Maintenance |
| grass debris especially around the engine cooling fins | |
|
|
|
|
|
| (also see engine manual) and the brake shoe. | ||
|
|
|
|
|
|
| ||
Changing oil: | Check the cutting action (see “Adjusting the Blades”) | |||||||
and lightly oil the cutting edges. | ||||||||
Change the oil after 2 hours of use. The oil should | ||||||||
Check that all nuts and bolts are tight. | ||||||||
then be changed every 50 hours or at the end of each | ||||||||
| ||||||||
season before storage, whichever is sooner. | Drain off any fuel in the petrol tank by: | |||||||
Change the oil as follows: | – Removing the pipe from the carburettor and emp- | |||||||
Note: The oil will drain more freely if the engine is | tying the fuel into a can. | |||||||
| ||||||||
warm. | – Run the engine for a few minutes until the engine | |||||||
|
|
|
|
|
|
| stops. | |
| L |
|
|
|
| |||
|
| – Remove the carburettor bowl by removing nut, | ||||||
1. Clean area around the rear lower oil drain plug 30 | ||||||||
and drain off any fuel in the carburettor. This will | ||||||||
| and remove plug. | |||||||
| prevent gum (fuel deposits) forming on essential | |||||||
2. Screw the oil drain tube 31 assembly. | ||||||||
carburettor parts. | ||||||||
3.Tip the mower back and drain the oil into a suita- ble container. Ensure that all the old oil has drained away.
4.Refit the oil drain plug 30.
5.Clean the area around the oil fill dip stick 6 and re- move.
6.With the mower on level ground slowly pour a good quality SAE 30 oil (i. e. SAE 30 API SF), in small quantities, into the oil filler hole. The correct level on the dip stick 9. Depending on any residual of oil in the sump, up to 0,6 litres (1.1 pint) oil will be required to fill the engine.
7.Refit the oil fill dip stick 6.
Note: It is important that you use the recommended oil to avoid damage to your engine.
Cleaning Air filter (See engine manual for details).
General maintenance and Adjustments (See engine manual for details).
Change the oil and clean the air filter. (Winter storage only. See engine manual for details).
Recharge the battery once during winter storage (re- fer to “Battery Maintenance”).
17 • F016 L69 838 • TMS • 11.07.01 | English - 5 |
